Professional Documents
Culture Documents
NT - Bosch - Dcu15 - Iveco: Ecu Connector
NT - Bosch - Dcu15 - Iveco: Ecu Connector
00
DIRECT CONNECTION
In order to connect to the ECU use the CABLE F32GN037C.
Make sure that the POWER led (red) on NEW TRASDATA is ON.
ECU CONNECTOR
Dimsport s.r.l –15020 Serralunga di Crea (AL) - Italy- Tel. +39014295201 – WEB : www.dimsport.com -3-
NT_BOSCH_DCU15_IVECO VER 02.00
Warning: for a correct communication with the ECU it is necessary to LIFT the pin of the
specific chip shown in the picture below. Solder it back before placing the ECU back into
the vehicle.
Dimsport s.r.l –15020 Serralunga di Crea (AL) - Italy- Tel. +39014295201 – WEB : www.dimsport.com -4-
NT_BOSCH_DCU15_IVECO VER 02.00
RX & TX CONNECTION
For the RX & TX connections it is necessary to use the F34NTF53 flat cable.
Dimsport s.r.l –15020 Serralunga di Crea (AL) - Italy- Tel. +39014295201 – WEB : www.dimsport.com -5-
NT_BOSCH_DCU15_IVECO VER 02.00
BOOT&CNF1 CONNECTION
Connect the GREY and BLUE wires of the cable F32GN037C as described here below :
Dimsport s.r.l –15020 Serralunga di Crea (AL) - Italy- Tel. +39014295201 – WEB : www.dimsport.com -6-