Professional Documents
Culture Documents
PAT Status:: Mobitel
PAT Status:: Mobitel
PAT Status:: Mobitel
MOBITEL
bite Huawei BTS PAT Document Page 1 of 14
w C:art, Aiwayx.
Ver. 2018-03-21
11-1 UA et 6ri
wivr)
Site ID Project Stage
Regional 0 & M Head: Ramesh Sanjaya
Preliminary Inspection
BTS Installation
10157RRU TYPE:
PAT Status:
*Checked
• Pass 0
• Reject .................................
.......... C..1^-fr'VLI4P7'
Regional Operation Gampaha.
• Pass with Minor [DV Mobitel Reg
Remarks:
tu.1°
kith II
Major — Affects human safety, equipment safety, service quality and long term operations
Minor — Does not affect human safety and/or equipment
ri Lanka
Te ecorn
,obite
MOBITEL
Huawei BTS PAT Document Page 2 of 14
We. Core_ Alw.,,,,
%oft
',me"' ,11111P.
Ver. 2018-03-21
H U4AVVE I .
Site ID Project Stage
Regional 0 & M Head: Ramesh Sanjaya
Major
ot
or OK Comment
NOK
Minor
1.00 Earthing
Feeder cable earth connected to ECB at 90 bend,
1.01 Major
within lm (Vertical rise)
Feeder cable earth within lm from bottom feeder
1.02 Major "1 tA
connector
If vertical feeder length >30m additional feeder
1.03 Major 0 /A
cable earth connected to ECB at every 30m level
Feeder cable earth within lm from top feeder
1.04 Major
connector 0/A
If horizontal feeder length >20m additional feeder
1.05 cable earth connected to ECB at every 20m Major a/ A
distance
1.06 TMA Earthing through proper clamping on tower Major or J A
Major — Affects human safety, equipment safety, service quality and long term operations
Minor — Does not affect human safety and/or equipment
Te 1 gicLan ka
MOBITEL
• ,, bite!
Huawei BTS PAT Document Page 3 of 14
We- Core_ Aisvey,r-
Ver. 2018-03-21
H UAVVE1
Site ID Project Stage
Regional 0 & M Head: Ramesh Sanjaya
1.18 Tower ECBs are earthed using 35mm2 earth cable Major v--- efi s-SA--i ,
RRU DC power cable shield should be earthed at
1.19 Major 1-'"
the BTS end
RRU should be earthed using 16mm2 earth cable to
1.20 Major V"
ECB
2.04 Cabinet door can be locked and unlocked easily Minor t----
Power supply system is secured properly to the
2.05 Major v
floor or plinth
Battery terminal tightening is done during the PAT
2.06 using a torque wrench (Shoto: 9-11Nm, Major i"-
Leoch: 3.9-5.4Nm)
2.07 Battery breather lines are installed properly Major 1.- --
Battery system is installed properly. 35mm2 DC
2.j
08
cables from battery cabinet are secured with GI
Ma or t•
No. of batteries installed 4i5 "-°5
coated flexible PVC if less than 5m and GI pipe if
more than or equal 5m Battery type & capacity -teoCk UT
0
HUAWEI
el. Ver. 2018-03-21
Site ID Project Stage
Regional 0 & M Head: Ramesh Sanjaya
. bite!
MOBITEL
Huawei BTS PAT Document Page 5 of 14
we ,-,e_ Aiwa,.
Ver. 2018-03-21
H IJAVVE I
Site ID Project Stage
Regional 0 & M Head: Ramesh Sanjaya
Sector A/P/W
4.04 Bottom jumper type Minor — ...
Sector B/Q/X
Sector C/R/Y
Sector A/P/W —
4.06 Bottom jumper length Minor ,-
Sector B/Q/X
Sector C/R/Y
Major — Affects human safety, equipment safety, sery ce quality and long term operations
Minor — Does not affect human safety and/or equipment
sricLanka
Tei
e
'
'bttt
MO BITEL
Huawei BTS PAT Document Page 6 of 14
ar,
H WM/tie I
Ver. 2018-03-21
Site ID Project Stage
Regional 0 & M Head: Ramesh Sanjaya
Sector A/P/W
4.07 Feeder clamping (Distance < 1.5m) Major ,___
Sector B/Q/X
Sector C/R/Y
Sector C/R/Y 14
V
Sector A/P/W
4.09Fveff-e-irb
fi re labelling Major 1,,- ti
Sector B/Q/X
Sector C/R/Y
Sector Al/P1/W1 v-
Um-der/fibre inlet & other cable openings are Sector A2/P2/W2 t7-•
4.10 sealed properly using durable UV-resistant Major 1/- Sector B1/Q1/X1 v-
products Sector B2/Q2/X2 ve—
Sector C1/R1/Y1 V
Sector C2/R2/Y2 17-
GPS antenna installation and cable routing are
4.11 done properly (Using clamps when fixing to tower Major ''.--
member and cable ladder)
c.4 i)0 -i- 4--
4.12 Antenna type & model (Manufacture Code No.) Major
Sector A/P/W
4.15 Antenna at correct height Major it.7 Sector B/Q/X v/.
17
Sector C/R/Y
Major — Affects human safety, equipment safety, service quality and long term operations
Minor — Does not affect human safety and/or equipment
sr:icLanka
T i
.obitel
MOBITEL
Huawei BTS PAT Document Page 7 of 14
41'a. Carat_ Rlwayv_
Major — Affects human safety, equipment safety, sery ce quality and long term operations
Minor — Does not affect human safety and/or equipment
Te 1 gicLan ka
:obit&
MOBITEL
Huawei BTS PAT Document Page 8 of 14
await..
,INP,
Ver. 2018-03-21
H UAVVE I
Site ID Project Stage
Regional 0 & M Head: Ramesh Sanjaya
Ver. 2018-03-21
0-1 LIAM/1E I
Site ID Project Stage
Regional 0 & M Head: Ramesh Sanjaya
. bite!
MOBITEL
Huawei BTS PAT Document Page 10 of 14
OF Ver. 2018-03-21
N-1LJAVVE 1
Site ID Project Stage
Regional 0 & M Head: Ramesh Sanjaya
9.37 Monitoring Module (SMU) Type t'l° c'213 . S/N '24 02-3 le)&12->C/31-J43c)(7-27 /3
„go__
......
HLIAWEI
Ver. 2018-03-21
Site ID Project Stage
Regional 0 & M Head: Ramesh Sanjaya
10.00 Miscellaneous
10.03 Retain the additional engineering materials Minor ---- Bonding tapes, insulation tapes etc.
for future use
Major — Affects human safety, equipment safety, service quality and long term operations
Minor — Does not affect human safety and/or equipment
sricLanka
Tei
.obitel
MOBITEL
Huawei BTS PAT Document Page 12 of 14
VI KA Ver. 2018-03-21
HILJAWEI
Site ID Project Stage
Regional 0 & M Head: Ramesh Sanjaya
Ver. 2018-03-21
H LSAVVE I
Site ID P roject Stage
Regional 0 & M Head: Ramesh Sanjaya
Major — Affects human safety, equipment safety, service quality and long term operations
Minor — Does not affect human safety and/or equipment
Te 1 gicLanka
.obitel
MOBITEL
Huawei BTS PAT Document Page 14 of 14
We- Cart, Aiwa,-
Ver. 2018-03-21
H UA El
Site ID Project Stage
Regional 0 & M Head: Ramesh Sanjaya
BTS check list shall be verified and attached with this document.
Following conditions will be checked before issuing the FAC other than the contractual FAC obligations.
+ Battery performance test will be carried out by Mobitel after 2 months period and if the
performances are low, Huawei is responsible to address the issues
+ If the Bit Error Rate too high appears in 2 months period because of the El cable from TX
devices to BBU, then Huawei is responsible to address the issue (Mobitel will perform the
test for fault identification)
+ If the Packet Loss too high appears in 2 months period because of the FE cable from TX
devices to BBU, then Huawei is responsible to address the issue (Mobitel will perform the
test for fault identification)
+ The values of VSWR & DTF between 1.3-1.4 & 1.04-1.05 respectively will be re-tested by
Mobitel after 2 months period and if the values are further increased, Huawei is responsible
to clear issues related to VSWR & DTF at that time
+ External Alarm Test should be according the finalization monitoring solution
+ The period is calculated from the date of the accepted PAT
Frequency Band: L1
Date: 2_4:10) 1 0512
t.„,c0,17
For Mobitel For-iftravrer Pio1 6c-E For Sub Contractor
Name: Name: Do W) Name: j . .5 at es ;tifre
Major — Affects human safety, equipment safety, service quality and long term operations
Minor — Does not affect human safety and/or equipment
w AT
Telecom MOBITEL
Mobitel Huawei NodeB/eNodeB PAT Document 1 of 3
We Care. Always.
"SO
HuAvve s
67th \NAT ) $ 4i Ver. 2018-03-21
Site ID Project Stage
Regional 0 & M Head: Ramesh Sanjaya
Test Record
SN Item Sub Item Actual Record (If no test, please
Requirements
remark)
Phase to Neutral
Turn off the power for the cabinet and 9- 3 0 .V
AC power on securely fix all boards. Power on AC
power switch Neutral to Earth
C)- 1 .V
Major — Affects human safety, equipment safety, service quality and long term operations
Minor — Does not affect human safety and/or equipment
iLrita
Telecom
MOBITEL
Mobitel Huawei NodeB/eNodeB PAT Document 2 of 3
Ws. Cara. Always.
4,164A,
%lir
* ... ... Ver. 2018-03-21
H ILJAWE I Site ID Project Stage
Regional 0 & M Head: Ramesh Sanjaya
At UE connection mode and near the site Measure from INOC or RNC
(NodeB): CPICH_RSCP > -85 dBm remotely dBm
At UE connection mode and near the site Measure from INOC or RNC
Signal quality (NodeB): CPICH_Ecno > -8 dB remotely dB
(Optional)
At UE connection mode and near the site
(eNodeB): RSRP > -90 dBm Measure remotely .....dBm
Alarm Check whether there are existing major This is to confirm that the
4 Alarm query
query alarms in NodeB/eNodeB NodeB/eNodeB alarms are visible
Major — Affects human safety, equipment safety, service quality and long term operations
Minor — Does not affect human safety and/or equipment
l Sri Lanka.
Teiecom MOBITEL
Ntobitel Huawei NodeB/eNodeB PAT Document 3 of 3
Wv Cara. Always.
40 Ver. 2018-03-21
14'
...
HuAwei Site ID Project Stage
Regional 0 & M Head: Ramesh Sanjaya
Major or
OK Not OK Comment
Minor
8.00 External Alarm Test by LMT
(PL
For Mobitel For 1avoci P1 0 ) cc4 For Sub Contractor
Name: Name: rDv\--:)-v,,J,‘"\ Name:4 . ow s iK2Z, ' Q_
Major - Affects human safety, equipment safety, service quality and long term operations
Minor - Does not affect human safety and/or equipment
S Lanka
Te ecom
Direct Implementation Project - Equipments Inventory
RRU/MRFUl /
RRU/MRFU2
RRU/MRFU3
RRU/MRFU 900
RRU/MRFU4
RRU/MRFU5
RRU/MRFU6
RRU/Mikftll 'v - @irit-JA7)
-
RRU/M-RFI42 ?. - - Gal v-ihrf)
RRU/MR-F-V3 t--- -- - ti M w 411
RRU/tilkfti 1800
RRU/MRFU4 -
_
RRU/MRFU5
RRU/MRFU6 —
BBU1 210 23/DL-IsfeieTT gq32733 L-- ._ -- CI rl (x44-7-I
BBU
BBU2 _
CC1 -
CC
CC2 -
FS1
FS
FS2
UBPG1
UBPG ___
UBPG2
_
BPC BPC1
BPC2
BPL
_
BPL1
—
BPL2
DDPU1
DDPU2
DDPU3
DDPU 1800
DDPU4
DDPU5
DDPU6 /
BBU 3806
WRFU
PSU
Mw IDU
Other
Tc3 u . ic) 2lati7 3 wriscro 24 3 6 t--- — — 611-1,-341 ,
AN 2)0 2.31.c w te.41 1.6c1'2 IS 21 -, -
1- ''' 0-qtri (A) AI)
P-11-6 5 0 0 alo 1-3 iero)Luv,3000 di 6 L'' "-- ,--- 61 M Ls; AI 1
Remarks
e._ -• A vt.,\--e_v,
.--'-
Removal Name '
,-----'-'
Signature
Date
New installation Name eAtAktlyerctl 9‘. 1) %Av, \ ,.....,_ ..^, ,y .67 s fi i az : v151441
etatoifot
Signature 1/4,
e-keLet-.2.--
---'=c1c---
_-__,----,-------
Date n ci 1, I® 5-- Ili ,-)._c:11 109 1,2.6 aotc‘ Icts 12.45
,