Professional Documents
Culture Documents
Citroen PDF
Citroen PDF
CITROEN IMMOBILISER
PAGE
CONTENTS
APPLICATIONS 1.1
1.1
CONNECTOR LOCATIONS
XANTIA
XSARA
SAXO
2.1
GENERAL OPERATION
INTRODUCTION
The Citroen Immobiliser systems are made up of 3 different types. They all perform vari-
ous functions, and it is important to understand the basic configuration and the types of
systems fitted.
This system was the first transponder system fitted to the Citroen range of vehicles, after
the keypad system was phased out. The system is a basic electronic control unit which
consists of immobiliser unit, and transponder aerial to pick up the transponder signal
code.
This system is similar to the GM immobiliser system, and is programmed and diagnosed
in much the same way.
The next generation of Immobiliser and alarm system produced the CPH system which
controls a number of additional components which further enhances the vehicle protec-
tion system. These include central door locking, ultrasonic passenger sensors to name a
few.
This system is programmed in much the same way, but offers additional functionality on
live data and actuators functions.
This is the latest system, and the alarm and immobiliser have now been incorporated into
the body control unit, which controls all body units, including wipers, indicators, lights,
doors, windows, locks, boot, service interval, horn, etc.
Again, with all the BSI because the immobiliser is part of a complicated system there are
many more functions included, on actuators, special functions and live data.
3.1
SPECIAL FUNCTIONS
PROGRAMMING KEYS—IMMOBILISER
DIAGNOSTIC MENU
Select SPECIAL FUNCTIONS from the
ECU IDENTIFICATION Diagnostic Menu using the UP and
FAULT CODES DOWN arrows.
LIVE DATA
Then press the ENTER key.
ACTUATORS
SPECIAL FUNCTIONS
PRESS ENTER KEY
DIAGNOSTIC MENU
Using the UP and DOWn keys select
PROGRAM KEYS the PROGRAM KEYS option
IS THIS CORRECT
OK=ENTER CLEAR=BACK
4.1
SPECIAL FUNCTIONS
Cont’d
4.2
SPECIAL FUNCTIONS
DIAGNOSTIC MENU
Select SPECIAL FUNCTIONS from the
ECU IDENTIFICATION Diagnostic Menu using the UP and
FAULT CODES DOWN arrows.
LIVE DATA
Then press the ENTER key.
ACTUATORS
SPECIAL FUNCTIONS
NOTE : ENSURE ALL DOORS AL
PRESS ENTER KEY CLOSED WHEN KEY PROGRAM-
MING IS BEING PERFORMED.
DIAGNOSTIC MENU
PRESS ENTER KEY To enter the security code use the fol-
lowing procedure :-
SECURITY CODE Press to elect Number & Letter
4.3
SPECIAL FUNCTIONS
Cont’d
ERASING KEYS
PROGRAMMING KEYS
SWITCH IGNITION ON
SWITCH IGNITION ON
IGNITION STATUS OFF
4.4
SPECIAL FUNCTIONS
Cont’d
TRYING TO COMMUNICATE
4.5