Professional Documents
Culture Documents
Suggestions For Job Exams Printable Format PDF
Suggestions For Job Exams Printable Format PDF
Suggestions For Job Exams Printable Format PDF
Parvejul Islam)
Written Questions
For written test of PGCB or other companies that is taken by BUET.
Circuit:
DC circuit solution (Thevn. Maxm.Power,Super posn.,Nodal,Complex circuit etc.)
MCQ read from B.L.Theraja (Chapter 1, 2, 3) (1x 4)
AC circuit solution (AC fundamentals,V=vSinwt, Polar –rect related prob.) (1x 4)
Resonance circuit
MCQ read from B.L.Theraja
Electronics: (4x4=16)
Clippers, Clampers Circuit (Draw i/p, o/p curve) (1x 4)
Characteristics curves (all configurations)
DC biasing (Fixed-bias, Emitter-stabilized bias, Voltage-divider bias, DC bias with
voltage feedback circuit, try to solve critical configuration and with PNP) (1x 4)
Read summary from end of the chapter 2, 3, 4, 5
Op-amp (Inverting, Non-inverting and Summing amplifier) (1x 4)
Integrator, Differentiator circuit (draw o/p curves with i/p sine, square waves)
Active Filter (draw circuit diagram, Response curve)
Draw single & three phases Circuit diagram, input, output curves (Rectifier, Inverter)
(1x4)
Digital Electronics (Less Impt. for BUET Exam )
Show that a positive-logic NOR gate is the same physical gate as a negative-logic NAND
and vice versa
Show that a positive-logic AND gate is the same physical gate as a negative-logic OR
and vice versa
Basic gate implement with NOR and NAND gate
Machine: (2x4=8)
Problem on Transformer test, loss and efficiency calculation, (1x 4)
Condition for Parallel operation of single-phase & three-phase Transformer
Clear concept on V-V connection and Vector Group
Instrument transformer
Difference between generator and motor (1x4)
Significance of the Back EMF
Torque and power relation
Why Starter use?
Equivalent circuit of an Induction motor
Slip and related problem
Full-load torque, Maximum torque and starting torque related problem
Power stages in an Induction motor and related problem
Why starter use in Induction motor?
What is synchronizing?
Condition for synchronizing of a single and three-phase Alternator
V-curve
Comparison between Synchronous Motor and Induction Motor
Communication: (3x4=12)
Modulation & Demodulation (definition, input/output waveform, modulation index,
equation, and problem)
Digital Modulation (input/output waveform, equation)
Nyquist Sampling Theorem
Bit Error Rate (BER) related problem
Define Erlang, One Erlang and related problems
OSI reference model and functions
Serial & Parallel data transmission
General, Power and Communication related Abbreviations
PGCB (BUET):
General Math
Correct Sentence
General Knowledge (Multiple Choice)
Elaboration (BCMCL, NAFF,BGFCL, BPC)
Write the Company name [Total Gas(British) , Cairn Energy (France),
What do mean by Dyn11 (Primary Delta, Secondary Star with Neutral & 600 Phase
shift.)
Commercial Radio Frequency Range (87.5~108.0 MHz)
By Nodal analysis find Current ‘I’ (A diagram of a circuit is supposed to be here.)
Problem on Maximum Power Transfer For three sources.
Design the Op-Amp output for 3V1+V2
Clipping Circuit.
Abbreviations: OFDM, GSM, VSAT, PABX, ATM, SONET
For a 230/460 V, 46000VA Transformer to maintain 400 volt at Secondary find the
Primary Terminal Voltage.
A Generator of 30MVA, 13.2KV, 20% Reactance supplied to a motor of 12.8 KV, 20%
Reactance by a trans former of 10% reactance. If fault occur to the motor side. Find fault
current.
In case of two Wattmeter power measuring method W1=4000, W2=-1000. find Power
factor Cosθ=?, Power=?
Draw Torque speed curve of Synchronous motor and three phase Induction motor.
Draw the circuit diagram & Output shape of two value capacitor single phase induction
motor.
EGCB (DUET):
DPDB (BUET):
General Math
Translation (Bangla to Eng.)
Elaboration (General Knowledge)
General Knowledge (Multiple Choice)
Problem of Maximum Power transfer in case of DC circuit (B.L.Thereja)
Nodal Analysis with current & Voltage source mix.
Objective (Chapter end objective of B.L.Thereja).
True-False
Clipping Circuit
Erlang (E) Problem on Traffic signal of GSM system (Ref: GSM by Ericsion)
Traffic per node =10/20=0.5E
No of call per server = 30/3=10
No of call by group server = 10*20=200 callls.
Show that Serial data transfer required less memory than parallel data transfer at counter
to counter.
For a 230/460 V, 46000VA Transformer to maintain 400 volt at Secondary find the
Primary Terminal Voltage (Unknown).
A Generator of 30MVA, 13.2KV, 20% Reactance supplied to a motor of 12.8 KV, 20%
Reactance by a trans former of 10% reactance. If fault occur to the motor side. Find fault
current. (Stevenson Jr. 257 page).
Draw the Zero sequence network of the given circuit. (Example Stevenson Jr.)
Draw the Torque speed curve of Induction Motor at Variable Resistance.
In case of two Wattmeter power measuring method W1=4000, W2=-1000. find Power
factor Cosθ=?, Power=?
PGCB
some old question:
http://xa.yimg.com/kq/groups/14569883/714256576/name/PDB
http://xa.yimg.com/kq/groups/14569883/2041305556/name/PDB
Marks Distribution
Total Marks: 100 /80 Time: 1:30 /1:00 Hours
1. English: 10/15
Translations
Correction of Sentences
Phrase Idioms
Small Paragraph etc.
4. Department: 50/60
Very Short Quest. / MCQ: 10/15
Medium Quest. / Mathematical: 35/40
EGCB:
1. Explain about myself,
2. What is steam turbine and its principle.
3. What is Calorific Value of a fuel.
4. What is its unit (Ans: BTU, KCal, joule)
5. Different types of protection of Alt. & Transformer.
6. What is in X-former tank (Ans: Core, Oil, Winding)
7. What is the work of X-former oil (Ans: Insulator, Minimize arc, cooling agent)
8. What is the unit of oil Dielectric strength (KV/cm)
9. What is world wide generation AC voltage (Ans: 11KV)
10. Which is the biggest power station of Bangladesh (Ghorashal , 950 MW)
11. Total Installed capacity of Bangladesh (Asn: 5245MW)
12. Which is the major fuel for generation (Gas)
13. Parallel Operation of 3 Phase x-former.
14. Name Plate on a X-former (%Z, Turn Ratio, KVA, Current rating, Origin of
manufacture, Dielectric strength of oil, Frequency etc.
try to cover some important networking based commands according to your own judgment
BOOKS NEEDED:
WIKIPEDIA & GOOGLE are your best teacher in this moment.(most of the cases, just basic
knowledge of everything is enough to satisfy employers) *I received these info from my seniors
ABBREVIATIONS
General:
1. OPEC--Organization of the Petroleum Exporting Countries
2. APEC--Asia-Pacific Economic Cooperation
3. NIPSOM--The National Institute of Preventive and Social Medicine
4. HBFC--HOUSE BUILDING FINANCE CORPORATION
5. ESCAP--Economic and Social Commission for Asia and the Pacific
6. BIMSTEC--Bay of Bengal Initiative for Multi Sectoral Technical and Economic
Cooperation
7. ETC--European Travel Commission
8. PAMA--The Professional Aviation Maintenance Association
9. DAMA--the Data Management Association
10. ISBN--The International Standard Book Number
11. T&T--Trinidad and Tobago
12. NHRC- National Human Rights Commission
13. UNESCO- United Nations Educational, Scientific & Cultural Organisation
14. IME- Institute Of Marine Engineers
15. BREB- Bangladesh Rural Electrification Board
16. BTMC- Bangladesh Textile Mills Corporation
17. ICAB- Institute Of Chartered Accountants of Bangladesh
18. BJIT Limited - Bangladesh Japan Information Technology
19. TIFA = Tax Increment Financing Authority
20. BPATC- Bangladesh Public Administration Training Centre
21. SPARRSO-Space Research and Remote Sensing Organization (Bangladesh)
22. IFAD--The International Fund for Agricultural Development
23. IUCN--the International Union for Conservation of Nature
24. Swine Flue Virus (H1N1) Comes From Pig/Swine
Engineering:
1. GPS--Global Positioning System
2. QPSK-- Quadrature phase-shift keying
3. GPRS--General Packet Radio Service
4. CTBT--The Comprehensive Test Ban Treaty
5. STM--Scanning tunneling microscope
6. SONET--Synchronous optical networking
7. VSAT--Very Small Aperture Terminal
8. VSWR--voltage standing wave ratio
9. ATM--Asynchronous Transfer Mode
10. ATM--automated teller machine
11. PABX--Private Automatic Branch Exchange
12. AMTOB--Association of Mobile Telecom Operations in Bangladesh
13. ADSL--Asymmetric Digital Subscriber Line
14. CDMA--Code division multiple access
15. DVD--Digital Versatile/Video Disc
16. DVDR--Digital Versatile/Video Disc Recordable
17. SCPC--Single channel per carrier
18. NMS--Network Management System
19. TDMA--Time division multiple access
20. FTDMA--Frequency-Time Division Multiple Access
21. DNS--Domain Name System
22. PSTN--Public switched telephone network
23. TCP/IP--The Transmission Control Protocol/Internet Protocol
24. USB--Universal Serial Bus
25. OMR & OCR-- Optical Mark Recognition & Optical Character Recognition
26. ICR--Intelligent Character Recognition
27. SCADA -- Supervisory Control And Data Acquisition
28. Radar-- Radio Detection & Ranging
29. RDF -- Radio Direction Finder
30. VSAT-- Very Small Aperture Terminal
31. ISD--International Subscriber Dialing
32. ISDN--International Subscriber Dialing Network
33. OFDM- Orthogonal Frequency Division Multiple Access
34. GSM- Global System for Mobile Communication