Professional Documents
Culture Documents
Power Curber: 727 Bendix Drive PO Box 1639 Salisbury, NC USA 28146-1639 Tel. 704-636-5871 Fax. 704-633-8140
Power Curber: 727 Bendix Drive PO Box 1639 Salisbury, NC USA 28146-1639 Tel. 704-636-5871 Fax. 704-633-8140
PO Box 1639
Salisbury, NC USA 28146-1639
Tel. 704-636-5871
Fax. 704-633-8140
Website. WWW.powercurbers.com
POWER CURBER
PARTS MANUAL
July 1, 2005
Revised 8-10-07
Introduction
Parts Order Information
Table of Abbreviations
Conversion Chart - Metric To English Units
Conversion Chart – English To Metric Units
The Spare Parts Catalog contains a list of illustrations at the start of each section. Each section gives figure number
and figure title. A visual and a corresponding description make up the figure. The description lists all available spare
parts. Each figure includes:
Only authorized personnel may order parts. Contact your Power Curber Distributor for ordering parts. See below
for Limited Warranty information. Please promptly fill out the Limited Warranty Card that is located in front of
the Operation Manual, and return it to Power Curbers, Inc. within ten (10) days of delivery to validate your
Power Curber Limited Warranty.
LIMITED WARRANTY
Power Curbers, Inc. warrants to the first purchaser of each new machine that the machine and the
component parts manufactured by Power Curbers were free of defects in material and workmanship at the
time of purchase. The obligation under this warranty is limited to the replacement or repair at our Salisbury,
North Carolina factory, or at a point designated by us, of such defective part, and is conditional upon notice
of any such defect within 180 days of shipment to the first purchaser.
This warranty does not obligate us to bear the cost of transportation or labor in connection with the
replacement or repair of defective parts. This warranty does not apply to a unit upon which repairs or
alterations have already been made unless such repairs or alterations were authorized by Power Curbers.
Accessories and components which are not manufactured by Power Curbers but which are included in
Power Curbers' products, are subject only to the warranties of their respective manufacturers.
Date Purchased
Power Curber Serial No.
Engine Model No.
Engine Spec. No.
Engine Serial No.
Optional Equip. Installed
Mold No. and Type
Personnel should use the following specific information When ordering engine parts, please give the engine
for ordering parts: type number and serial number taken from the I.D.
plate located on the engine crankcase (Figure 2). The
• Machine model number engine serial number is also stamped on the crankcase
(Figure 3).
• Machine serial number (Figure 1)
• Telephone
• Facsimile
Adjusting Adj.
As Required AR
Assembly Assy.
Circuit Breaker C.B.
Center Ctr.
Conveyor Conv.
Diameter Dia.
Front Frt.
Forward Fwd.
Gallon Gal.
Grade GR.
Inch In.
Inside Diameter I.D.
Includes Incl.
Left Rear L.R.
Long Lg.
Left Hand L.H.
Millimeter Mm
Maximum Max.
Minimum Min.
Not Shown NS
Not Sold Separately NSS
Outside Diameter O.D.
Pounds per Square Inch Psi
Right Hand R.H.
Right Rear RR.
Stainless Steel S.S.
Volt V.
Weldment Wmt.
*If the lift kit is ordered without A572442, order items 39 to 43 and vibrator extension hoses.
1 2
4
3