Professional Documents
Culture Documents
Safety Data Sheet (SDS) : Name of Chemical: Ralli Hand Sanitizer
Safety Data Sheet (SDS) : Name of Chemical: Ralli Hand Sanitizer
Safety Data Sheet (SDS) : Name of Chemical: Ralli Hand Sanitizer
2. HAZARD IDENTIFICATION
GHS02 GHS07
Fire extinguishing media Water spray Alcohol-resistant foam Dry chemical ,Carbon dioxide
(CO2)
Hazardous decomposition Carbon oxides
products
Special firefighting Do not use a solid water stream as it may scatter and spread fire.
procedure Flash back possible over considerable distance. Exposure to
combustion products may be a hazard to health Unsuitable
extinguishing media- High volume water jet
Precaution to Fire Fighters In the event of fire, wear self-contained breathing apparatus. Use
personal protective equipment.
Personal precaution Remove all sources of ignition. Use personal protective equipment.
Follow safe handling advice and personal protective equipment
recommendations.
Precautions for the Discharge into the environment must be avoided. Prevent further
environment leakage or spillage if safe to do so. Prevent spreading over a wide area
(e.g. by containment or oil barriers). Retain and dispose of contaminated
wash water. Local authorities should be advised if significant spillages
cannot be contained.
Clean up method Non-sparking tools should be used. Soak up with inert absorbent
material. Suppress (knock down) gases/vapors/mists with a water spray
jet. For large spills, provide diking or other appropriate containment to
keep material from spreading. If diked material can be pumped, store
recovered material in appropriate container. Clean up remaining
materials from spill with suitable absorbent. Local or national regulations
may apply to releases and disposal of this material, as well as those
materials and items employed in the cleanup of releases. You will need
to determine which regulations are applicable. Sections 13 and 15 of this
SDS provide information regarding certain local or national
requirements.
General Do not breathe vapors or spray mist. Do not swallow. Do not get in eyes.
precaution Avoid prolonged or repeated contact with skin. Handle in accordance with
good industrial hygiene and safety practice. Non-sparking tools should be
used. Keep container tightly closed. Keep away from heat and sources of
ignition. Take precautionary measures against static discharges. Take care
to prevent spills, waste and minimize release to the environment.
Personal Do not mix with bare hand. Use gumboots, mask, hand gloves, rubber apron,
protection hood or hat.
Storage Keep in properly labeled containers. Keep tightly closed. Keep in a cool, well-
ventilated place. Store in accordance with the particular national regulations.
Keep away from heat and sources of ignition.
Incompatibilities Strong oxidizing agents Organic peroxides Flammable solids Pyrophoric
liquids Pyrophoric solids Self-heating substances and mixtures Substances
and mixtures which in contact with water emit flammable gases Explosives
Gases
Personal protection
Skin Select appropriate protective clothing based Eyes Wear the following
on chemical resistance data and an personal protective
assessment of the local exposure potential. equipment: Safety
Wear the following personal protective goggles
equipment: Flame retardant antistatic
protective clothing. Skin contact must be
avoided by using impervious protective
clothing (gloves, aprons, boots, etc).
Respiration Follow OSHA respirator regulations (29 CFR Other Ensure that eye flushing
1910.134) and use NIOSH/MSHA approved systems and safety
respirators. Protection provided by air showers are located
purifying respirators against exposure to any close to the working
hazardous chemical is limited. Use a place. When using do
positive pressure air supplied respirator if not eat, drink or smoke.
there is any potential for uncontrolled Wash contaminated
release, exposure levels are unknown clothing before re-use.
Exposure limits
1000 ppm TLV-STEL NA
TLV-TWA 1880 mg/M 3
LEL % NA UEL % NA % NA
Volatile
Evaporation rate NA Viscosity @ 25 oC NA
SYMBOLS: Xi, F
PHRASES R:
R21 Harmful in contact with skin.
R22 Harmful if swallowed.
R36 Irritating to eyes.
R37 Irritating to respiratory system.
R20 Harmful by inhalation.
R25 Toxic if swallowed.
PHRASES S:
(S1/2): Keep locked up and out of the reach of children
S21: When using do not smoke
S26: In case of contact with eyes, rinse immediately with plenty of water and seek medical advice
S28: After contact with skin, wash immediately with plenty of ... (to be specified by the
manufacturer)
S36/37/39: Wear suitable protective clothing, gloves and eye/face protection
S45: In case of accident or if you feel unwell seek medical advice immediately (show the label
where possible)
NFPA Rating :
USE-
This is a personal care or cosmetic product that is safe for consumers and other users under
normal and reasonably foreseeable use. Cosmetics and consumer products,
The information provided in this safety data sheet is correct to the best of our
knowledge, information and belief at the data of its publication. The information given is
designed only as guidance for safe handling, use, processing, storage, transportation,
disposal and release and is not to be considered as a warranty or quality specification.
The information relates only to the specific material designated and may not be valid for
such material used in combination with other materials.
This data belongs to Rallis India Limited. All rights reserved.