Group 3 Electrical Component Specification

You might also like

Download as pdf or txt
Download as pdf or txt
You are on page 1of 8

GROUP 3 ELECTRICAL COMPONENT SPECIFICATION

Part name Symbol Specifications Check

ö Check specific gravity


12V Ý 160Ah 1.280 over : Over charged
Battery
(2EA) 1.280 ~ 1.250 : Normal
1.250 below : Recharging

Rated load  ö Check coil resistance(M4 to M4)


24V Normal : About 50̫
Battery relay
100A(continuity) ö Check contact
1000A(30seconds) Normal : â̫
CR-1

ö Check contact
Glow plug relay 24V 200A Normal : 0.942̫
(For terminal 1-GND)
CR-24
6
5
4
3
2
1

B ö Check contact
1

I ,O B-BR : 24V 1A OFF : â̫(For each terminal)


Start key B-ACC : 24V 10A
ON : 0̫(For terminal 1-3 and 1-2)
B-ST : 24V 40A
I I OH START : 0̫(For terminal 1-5)
6
5

3
2

CS AC B H

Pressure 1
switch Pa 10kgf/cm2 ö Check contact
2 (N.C TYPE) Normal : 0.1̫
(Travel,
working) CD-6 CD-7

4-20
Part name Symbol Specifications Check

Pressure switch 2 3~6kgf/cm2 ö Check contact


Pa
(For overload) 1 (N.O TYPE) Normal â̫

CD-37

ö Check resistance
Air gird heater 24V 200A
0.25~0.12̫

CN-78

C 1 ö Check resistance
Temperature
- 50ÁC : 804̫
sensor
2 80ÁC : 310̫
(Hydraulic)
CD-8 100ÁC : 180̫
CD-1 CD-8

Air cleaner - ö Check contact


Pa High level : â̫
pressure switch
Low level : 0̫
CD-10

ö Check resistance
Full : 50̫ 6/12 : 350̫
2 11/12 : 100̫ 5/12 : 400̫
Fuel sender 10/12 : 150̫ 4/12 : 450̫
1 -
9/12 : 200̫ 3/12 : 500̫
8/12 : 250̫ 2/12 : 550̫
CD-2 7/12 : 300̫ 1/12 : 600̫
Empty warning : 700̫

M- 6
6
M
5
M+ 5 ö Check resistance
NC 4 Normal : 9~10̫
Accel actuator 2
P- 3 - (For terminal 5-6)
3 1
SIG 2 0.8~1.2k̫
P+ 1 (For terminal 1-3)
CN-76

4-21
Part name Symbol Specifications Check

30
86
87a 87 85 ö Check resistance
87 Normal : About 160 ̫
Relay 85
86
24V 16A (For terminal 85-86)
30
87a
0̫(For terminal 30-87a)
CR-2 CR-5 CR-7 CR-13 â̫(For terminal 30-87)
CR-35 CR-36 CR-46

1
ö Check resistance
Solenoid valve 2
24V 1A Normal : 15~25̫
(For terminal 1-2)
CN-66
CN-66CN-68
CN-68CN-70 CN-88
CN-70
CN-88
CN-133 CN-133
CN-137 CN-137
CN-140

2
ö Check resistance
EPPR valve 700mA Normal : 15~25̫
1
(For terminal 1-2)

CN-75

1
öCheck resistance
Resistor 45̫ 20WÜ5% Normal : 45̫
2

CN-47

ö Check disconnection
Speaker 20W Normal : A few̫

CN-23(LH)
CN-24(RH)

10 9 8 7 6 5 4 3 2 1 ö Check contact
10 6 5
Normal
ON : 0 ̫(For terminal 1-5, 2-6)
Switch â̫(For terminal 5-7, 6-8)
24V 8A
(Locking type) OFF : â̫(For terminal 1-5, 2-6)
9 8 2 7 1
0 ̫(For terminal 5-7, 6-8)
CS-23 CS-27 CS-50 CS-52
CS-54 CS-82 CS-83 CS-84

4-22
Part name Symbol Specifications Check

ö Check resist
Normal : About 5k̫
A + (For terminal A-C)
Accel dial B S - Normal : About 5V
C - (For terminal A-C)
: 2~4.5V
CN-142
(For terminal C-B)

8
2
7

9
1

I
ö Check disconnection
Normal : 1.0̫
ON : 0̫(For terminal 1-5, 2-6)
Switch 24V 8A
5

10
â̫(For terminal 5-7, 6-8)
OFF : â̫(For terminal 1-5, 6-8)
3

10
2

6
1

4
5

8
9

0̫(For terminal 5-7, 6-8)


CS-67

2
Head lamp, 24V 70W ö Check disconnection
Work lamp, (H3 Type)
24V 70W : 10 ̫
Room lamp, 1 24V 10W
Cab lamp (Room lamp) 24V 10W : 50 ̫
CL-1 CL-3 CL-4 CL-5
CL-6 CL-8 CL-9

Beacon lamp 21V 70A öCheck disconnection


M (H1 type) Normal : A few̫

CL-7
CL-7
-

1 M 24V 10A öCheck resistance


Fuel filler pump
35˶ /min Normal : 1.0̫
2
CN-61

öCheck operation
1
Hour meter Supply power(24V) to terminal
h 16~32V
2 No.2 and connect terminal No.1
and ground
CN-48

4-23
Part name Symbol Specifications Check

öCheck operation
DC22~28V Supply power(24V) to each
Horn
2A
terminal and connect ground.

CN- 20, CN - 25

2 3 öCheck contact
1
Normal : 0̫(For terminal 1-2)
2 24V 15A â̫(For terminal 1-3)
Safety switch 1
(N.C TYPE)
3
Operating : â̫(For terminal 1-2)
1
0̫(For terminal 1-3)
CS-4

Safety switch 2 öCheck contact


24V
(Wiper cut
(N.C TYPE) Normal : 0̫(One pin to ground)
switch)

CS-20 CS-53

1
Receiver dryer P öCheck contact
24V 2.5A
2 Normal : â̫

CN-29

N.C 1
2

S.R- 3
4
S.L- 5
N.C 6
7
8
öCheck voltage
Cassette radio S.R+ 9
24V 2A 20~25V
10
11
12 (For terminal 10-14, 11-14)
S.L+ 13
14

CN-27

Washer pump öCheck contact


24V 3.8A
Normal : 10.7̫(For terminal 1-2)

CN-22

4-24
Part name Symbol Specifications Check

3 1
2

5 3

4
4
öCheck disconnection
Wiper motor 5 24V 2A
6 2 6
Normal : 7̫(For terminal 2-6)
M

CN-21

A 24V
DC/DC 24V 24V(A-B)
B GND 12V 3A
Converter 12V (B-C)
C 12V 12V
CN-138

öCheck coil resistance


Normal : About 1M̫
Cigar lighter 24V 5A 1.4W öCheck contact
Normal : â̫
Operating time : 5~15sec
CL-2

B+
U öCheck contact
Alternator 3 24V 55A Normal : 0̫(For terminal B+-I)
~ I 1
G Normal : 24~27.5V
R 2
CN-74

B
M
Delco Remy öCheck contact
Starter
28MT 24V Normal : 0.1̫
M

CN-45

öCheck contact
Travel alarm 24V 0.5A
Normal : 5.2̫

CN-65

4-25
Part name Symbol Specifications Check

1
Aircon öCheck contact
24V 79W
compressor Normal : 13.4̫
CN-28

öCheck contact
Start relay 24V 300A
Normal : 0.94̫(For terminal 1-2)

CR-23

2 öCheck resistance
Blower 24V 9.5A
Normal : 2.5̫(For terminal 1-2)
1

1 Lo 1 öCheck resistance
2 MH 3 Normal : 1.12̫(For terminal 4-2)
Aircon resistor -
3 ML 2 2.07̫(For terminal 2-3)
4 Hi 4 3.17̫(For terminal 3-1)

öCheck resistance
1 1Á
C OFF Normal : 0̫(For terminal 1-2),
Duct sensor

C ON the atmosphere temp :
2
Over 4ÁC

öCheck resistance
Switch 24V 2W
(Door) Normal : About 5M̫

CS-1 CS-1
CS-20 CS-53

4-26
Part name Symbol Specifications Check

2
öCheck contact
Quick coupling 24V 6A
1 Normal : 28.9M̫ (For terminal 1-2)

CN-140

Switch 1
(Power max, öCheck resistance
2 24V 6A Normal : â̫
one touch
decal, horn)
CS-5 CS-19
CS-26 CS-29

3 24V
2 SIG 0bar : 1V(For terminal 1-2)
Transducer 1
500bar 500bar : 5V(For terminal 1-2)
GND
CD-42 CD-43

3 24V
2
0bar : 1V(For terminal 1-2)
SIG
Transducer 50bar 50bar : 5V(For terminal 1-2)
1 GND
CD-44

öCheck disconnection
2
Fusible normal : 0̫
60A (Connect ring terminal and check
link 1
resist between terminal 1 and 2)
CN-60

öCheck disconnection
Master switch 6-36V Normal : 0.1̫

4-27

You might also like