Professional Documents
Culture Documents
General Information Removal and Installation
General Information Removal and Installation
General Information Removal and Installation
1. SPECIFICATIONS
Front heated
Pin No. Front heated Rear seats
(passenger seat)
(driver seat)
▷ Do not place anything on the seat that insulates against the heat, such as a blanket or
cushion.
▷ Make sure that the head restraints are in place and secured properly. Never drive the vehicle
with the head restraint removed.
▷ To minimize the injuries in a collision or an abrupt stop, make sure the seatback is in the
upright position before driving. If the seatback is reclined too much, the occupant could slide
under the seat belt in a collision or an abrupt stop and cannot be protected properly by the
airbag system.
4. MAJOR CHANGES
1) Rear Center Seat Belt
Rear center seat belt
Previous Current
3) Front Buckle
Driver's
Front buckle
Front buckle
Previous Current
a. Slide switch
Slide switch (Power seat) Slide switch (Manual seat)
Power seat: Moving the slide switch forward and rearward activates the slide motor to move the
seat forward and rearward.
03-10
Power seat: Moving the slide switch upward and downward moves the seat cushion upward and
downward.
c. Reclining (Seatback angle)
Reclining (Power seat) Reclining (Manual seat)
Power seat: Moving the upper part of the reclining switch forward and rearward activates the
reclining motor to move the seatback forward and rearward.
7410-00 03-11
Power seat: Moving the adjustment lever forward moves the lumbar support forward,
and moving the lever rearward moves the lumbar support rearward.
03-12
Sliding function
The seat can be moved forward/backward.
Seatback reclining
Rear RH seat
Rear armrest
Left
Right
7510-00 03-17
1) Configuration
The 3-point type seat belts are mounted on the driver's seat, passenger's seat and rear seats
(LH, RH, Center). The seat belts on the front seats (driver's/passenger's) include pretensioner
feature which rewinds the seat belt immediately to protect the occupant's face and chest when a
strong frontal collision occurs.
Front 3-point type seat belt
(Driver's & Passenger's seats)
Height adjuster
3-point type seat belt Rear 3-point type seat belt (RH)
(RR center, LH)
Pretensioner
03-22
- U: General child restraint system which should be fixed with the seat belt approved by official
institute.
- UF/SU: General child restraint system which should be fixed with the ISOFIX system approved
by official/semiofficial institute.
- X: Seat which is not allowed to use child restraint system.
7510-08 03-23
3) ISO FIX
▶ Installation using lower latch
- When installing ISOFIX child restraint system to the vehicle, all the seat belts in the rear seat
should be buckled.
- The mounting latches and anchors for the ISOFIX system are only for the child restraint
system, so DO NOT install any restraint system other than ISOFIX specifications, seat belt or
other device to these latches or anchors.
03-24
- There are anchors (for hook mounting) for fixing child restraint system, on the back side of the
rear seatback as shown in the figure.
- Route the belt of the child restraint system over the seatback of the rear seat.
- Attach the hook of the child restraint system belt to the anchor firmly, and securely tighten the
child restraint to the seat.
7410-01 03-25
Passenger seat
assembly
▶ Front
<LH> <RH>
▶ Rear
<LH> <RH>
RH
03-40
Securing point
Securing points