Professional Documents
Culture Documents
1.1. Daftar Spek. Peralatan Rig
1.1. Daftar Spek. Peralatan Rig
1.1. Daftar Spek. Peralatan Rig
- Drum : Double
- Manufacturer/Model : Any
- Main Drum Barrel : Any (inch) x Any (inch) long
- Main Drum Brakes : Ø Any (inch) x Any (inch)
- Hoisting Speed : Any (speeds)
- Input HP Rating : Min. 250
- Cooling system : Independent tank
- Grooving on Main Drum : 1” – 1-1/8”
- Single Load Line Capacity : Any (lbs)
- With Cathead 2 ea min or hydraulic to make up & break out
- Auxiliary Brake / Hydromatic Brake
- Crown Block Safety Devices
- Independent fresh water cooling system for Drawwork and Aux. Brake.
- Crown-O-Matic automatic disengaged clutch and activate brake
- C/w Prime Movers (engines)
- Emergency Shutdown
- In compliance with API 7K
A.3 1 Unit Drawworks Motor / Prime Mover Yes Mandatory/Milik Sendiri
- Manufacturer/Model : Any
- Powered by : Electric Motor or Engine
- Number of engine : Any
- Continuous rating, hp : Any
- Intermittent rating, hp : Any
- Cooling system: Independent tank
- Input horse power : Any
- C/w torque converter and spark arrestor
A.4 1 Reel Sand Line Yes Mandatory/Milik Sendiri
- Manufacturer/Model : Any
- Cable size : 9/16"
- Length : Min. 6,000 ft.
A.5 1 Unit Air Compressor Yes Mandatory/Milik Sendiri
- Manufacturer/Model : Ingersol Rand or equivalent
- The air system is powered by a Compressor driven by the Engine, with 15 HP
per unit and 200 gal receiving vessel
- C/w all necessary piping and controls.
B MAST
B.1 1 Unit Rig Mast Yes Mandatory/Milik Sendiri
- Raising method : Telescopic or specify
- Manufacturer/Model : Any
- Clear working height : Min. 60 ft
* enough to accommodate 2 jts pipe of R-2 per stand
- Fingerboard/Racking Platform Capacity : Able to stand 2-7/8” Tubing, 6.5 ppf,
R-2 with min. 1,000 m
- Hook load : Min. 100,000 lbs
- Set back capacity : Min. 100,000 lbs
- Crown Block Rating : 100 ton
- Crown Sheaves : Min. 4 ea
- Groove Line size : Any (inch)
- C/w Crown safety platform and handrails laders to crown, traveling block
carrying cradle
- Hydraulic outriggers : able for min. 50 mph wind velocity and all guide lines
* 1 (one) pair Standar Hand Gloves. Cotton polka dot. Purpose for light general
maintenance. Including replacement supplies if material is damaged, dirty or
non feasible to use
* 1 (one) pair Safety Shoes. Good condition, use safety toe and oil resistant.
Meet SNI or ANSI standard.
B). PPE for Specific Work
* 1 (one) pair General Purpose Safety Goggles, for personnel who handle
chemicals. Non-ventilated type, polycarbonate spectacle, clear lenses,
elastis/rubber head band, lenses cleaner. Meet SNI or ANSI standard.
* 1 (one) pair Earmuff, for personnel who works on high noise area. Earmuff can
be attached to safety helmet.
* 1 (one) each Industrial Dust Mask, for personnel who handle chemicals.
Organic vapor respirator dust for respirator. Surgical face masks are prohibited.
* 1 (one) each Full Face Shield and Apron, for personnel who handle grinding
activity or certain hazard from material transmitting. Shield can be attached to
safety helmet.
* 1 (one) pair Chemical Rubber Hand Gloves, for personnel who handling
chemical and goods at oil industry activities.
* 1 (one) pair Rain Coat, for personnel who works on rainy weather. Include shirt
and pants.
* 1 (one) lot Welding Protective Equipment, for welding activity. Including full
face helmet and goggles, respirators, jacket or leather apron, gloves.
* 2 (two) pair High Voltage Resistant Safety Gloves, for personnel who works on
high voltage electricity/equipment. Provide for electrician and assistant.
-
DOKUMEN TENDER NO. GKM...
LAMPIRAN I-B
RENCANA KERJA DAN SYARAT
- Manufacturer/Model : Any
- Brakes : Air brakes in all wheels
- Steering Hydraulic Powered
- Axles :
* Front : Any (axles),
* Rear : Any (axles)
- Number of Wheels : Any (each)
- Tires Types : Rough / Mud Terrain
- Tires Condition : Steering types shall be new / near new
- Transmission : Min. 3 speed
- Carrier Enginee also powered for Drawwork : Yes / No
- Hydraulic leveling jacks : Required
- Size Length x Width x Height : Any (ft)
- Total Weight (include Drawwork & Mast) : Any (Ton)
A.2 1 Unit Drawworks Yes
- Capable of work on string to a min. depth of 1,000 m, with 2-7/8” Tubing (J-55,
6.5 ppf) with weight in air of 32,000 lbs or 2-7/8” DP (Grade G, 10.4 ppf) with
weight on air of 52,000 lbs. The drawworks power must be sufficient to trip drill
pipe in open hole at 60 ft/min with at least 20% spare capacity.
- Drum : Double
- Manufacturer/Model : Any
- Main Drum Barrel : Any (inch) x Any (inch) long
- Main Drum Brakes : Ø Any (inch) x Any (inch)
- Hoisting Speed : Any (speeds)
- Input HP Rating : Min. 250
- Cooling system : Independent tank
- Grooving on Main Drum : 1” – 1-1/8”
- Single Load Line Capacity : Any (lbs)
- With Cathead 2 ea min or hydraulic to make up & break out
- Auxiliary Brake / Hydromatic Brake
- Crown Block Safety Devices
- Independent fresh water cooling system for Drawwork and Aux. Brake.
- Crown-O-Matic automatic disengaged clutch and activate brake
- C/w Prime Movers (engines)
DOKUMEN TENDER NO. GKM...
LAMPIRAN I-B
RENCANA KERJA DAN SYARAT
- Manufacturer/Model : Any
- Powered by : Electric Motor or Engine
- Number of engine : Any
- Continuous rating, hp : Any
- Intermittent rating, hp : Any
- Cooling system: Independent tank
- Input horse power : Any
- C/w torque converter and spark arrestor
A.4 1 Reel Sand Line Yes
- Manufacturer/Model : Any
- Cable size : 9/16"
- Length : Min. 6,000 ft.
A.5 1 Unit Air Compressor Yes
- Manufacturer/Model : Any
- Steel Fixed or Telescopic Structure
- Clear woking height under rotary beam : Min. 16 ft height (sufficient space to
accommodate BOP stack height Class III, consist of Bell Nipple, Annular,
Double Rams, Spool)
- Manufacturer/Model : Any
- Adjustable Steel Platform
- Dimension of Floor Length x Width : Any (ft)
- Static Load : Min. 5,000 lbs
- Clear woking height : Min. 16 ft height (or sufficient space to accommodate
BOP stack height Class III, consist of Bell Nipple, Annular, Double Rams, Spool)
- Standard Type
- Dimension : Any (ft)
C.6 1 Lot Lighting for Substrucure and Drill Floor
- Sufficient lighting at Substrucure and Drill Floor area to allow Operation at night
- Manufacturer/Model : Any
- Death strength rating Capacity : Min. 75 ton
- C/w standard and extra long Links for cementing
- All Elevator Links rated for min. 75 ton
- Match to Drum and Mast
D.4 1 Each Swivel Yes
- Manufacturer/Model : Any
- Capacity : Min. 100 ton
- Pressure rating : Min. 3,000 psi
- Length : Any (ft)
- Able to connect to Kelly
D.5 1 Each Kelly 3-1/2" (with scabboard)
- Model : Square or Hexagonal
- Length : 34 - 40 ft working space
- Drive Bushing matched to Rotary Table
- C/w Upper & Lower Kelly Cock
D.6 2 Each Hoist
- Type : Hydraulic or Pneumatic hoist
- Wire rope size : Any (inch)
- Capacity : Min. 6,000 lbs each
- C/w brand new cable and a guide to ensure the cable is properly wound on the
drum when hoist is operated
- For pneumatic hoist, a separate dedicated compressor & suitable size air tank
must be provided to operate hoist only
E PUMP AUXILARIES
E.1 1 Unit Mud Pump Yes
- Mud tank/mixing area must be equipped with eyewash station and chemical
safety shower
- Specify dimension each Mud Tanks (length x width x height)
F.2 1 Unit Mud Hoppers & Mixing Pump Yes
- For active and pre-mix tanks with separate suction lines and flexible / separate
discharge lines
- C/w fluid and chemical shearing devices using impingement plates, piping,
valves, sack support.
- Dedicated centrifugal pump and 60 HP electric motor
F.3 1 Set Mud Agitator Yes
- Manufacturer/Model : Any
- Type and Pressure Rating : Any
- Connection Top and Bottom : Any
- Rubbers elements : 1 ea used and 1 ea spare
- Dimensions Height : Any (ft)
G.2 1 Unit Single Ram BOP 11" - 3K or 5K psi WP Yes
- Manufacturer/Model : Any
- Type and Pressure Rating : Any
- Connection Top and Bottom : Any
- Dimensions Height : Any (ft)
G.3 1 Lot Pipe and Blind Ram Stock for BOP 11” - 3K or 5K psi WP
- Blind rams : 2 set
- Type and Pressure Rating : Any
- Pipe rams 2-7/8" : 2 set
- Pipe rams 3-1/2" : 2 set
- C/w spare set of front packer, top seal and ring gasket as required
G.4 1 Unit Annular BOP 7" - 3K or 5K psi WP Yes
- Manufacturer/Model : Any
- Type and Pressure Rating : Any
- Connection Top and Bottom : Any
- Rubbers elements : 1 ea used and 1 ea spare
- Dimensions Height : Any (ft)
G.5 1 Unit Double Ram BOP 7" - 3K or 5K psi WP Yes
- Manufacturer/Model : Any
- Type and Pressure Rating : Any
- Connection Top and Bottom : Any
- Dimensions Height : Any (ft)
G.6 1 Lot Pipe and Blind Ram Stock for BOP 7” – 3K or 5K psi WP
- Blind rams : 2 set
- Pipe rams 2-7/8" : 2 set
- Pipe rams 3-1/2" : 2 set
- C/w spare set of front packer, top seal and ring gasket as required
G.7 1 Unit Accumulator Unit Yes
- Manufacturer/Model : Any
- Skid Mounted and covered in area
- Working pressure 3,000 psi with capacity min 80 gallon
- Capable to close-open-close BOPE, without electric system, as per API
- Min. 4 station, Compressor automatically start, with remote control in rig floor
- Contractor should provide a complete list of all subs to be provided, with full
dimensions.
K.10 1 Set Sucker Rod Hook Yes
- Capacity: Min. 25 tons.
DOKUMEN TENDER NO. GKM...
LAMPIRAN I-B
RENCANA KERJA DAN SYARAT
* 1 (one) pair Standar Hand Gloves. Cotton polka dot. Purpose for light general
maintenance. Including replacement supplies if material is damaged, dirty or
non feasible to use
* 1 (one) pair Safety Shoes. Good condition, use safety toe and oil resistant.
Meet SNI or ANSI standard.
B). PPE for Specific Work
* 1 (one) pair General Purpose Safety Goggles, for personnel who handle
chemicals. Non-ventilated type, polycarbonate spectacle, clear lenses,
elastis/rubber head band, lenses cleaner. Meet SNI or ANSI standard.
* 1 (one) pair Earmuff, for personnel who works on high noise area. Earmuff can
be attached to safety helmet.
* 1 (one) each Industrial Dust Mask, for personnel who handle chemicals.
Organic vapor respirator dust for respirator. Surgical face masks are prohibited.
DOKUMEN TENDER NO. GKM...
LAMPIRAN I-B
RENCANA KERJA DAN SYARAT
* 2 (two) pair High Voltage Resistant Safety Gloves, for personnel who works on
high voltage electricity/equipment. Provide for electrician and assistant.
Catatan:
1) Peralatan Mandatory merupakan peralatan yang wajib dimiliki oleh Kontraktor / Peserta Tender dengan status kepemilikan adalah Milik Sendiri.
2) Peralatan yang bukan dalam syarat Mandatory, wajib dicantumkan status kepemilikan dan dilengkapi supporting letter yang berlaku.
3) Panitia akan melakukan inspeksi visual dan mencatat keberadaan ada atau tidaknya peralatan yang ditawarkan oleh Peserta Tender.
DOKUMEN TENDER NO. GKM...
LAMPIRAN I-B
RENCANA KERJA DAN SYARAT
EMILIKAN
KETERANGAN
Mandatory/Milik Sendiri
Mandatory/Milik Sendiri
DOKUMEN TENDER NO. GKM...
LAMPIRAN I-B
RENCANA KERJA DAN SYARAT
EMILIKAN
KETERANGAN
Mandatory/Milik Sendiri
Mandatory/Milik Sendiri
Mandatory/Milik Sendiri
Mandatory/Milik Sendiri
Mandatory/Milik Sendiri
Mandatory/Milik Sendiri
DOKUMEN TENDER NO. GKM...
LAMPIRAN I-B
RENCANA KERJA DAN SYARAT
EMILIKAN
KETERANGAN
Mandatory/Milik Sendiri
Mandatory/Milik Sendiri
Mandatory/Milik Sendiri
Mandatory/Milik Sendiri
Mandatory/Milik Sendiri
DOKUMEN TENDER NO. GKM...
LAMPIRAN I-B
RENCANA KERJA DAN SYARAT
EMILIKAN
KETERANGAN
Mandatory/Milik Sendiri
Mandatory/Milik Sendiri
Mandatory/Milik Sendiri
Mandatory/Milik Sendiri
DOKUMEN TENDER NO. GKM...
LAMPIRAN I-B
RENCANA KERJA DAN SYARAT
EMILIKAN
KETERANGAN
Mandatory/Milik Sendiri
Mandatory/Milik Sendiri
Mandatory/Milik Sendiri
DOKUMEN TENDER NO. GKM...
LAMPIRAN I-B
RENCANA KERJA DAN SYARAT
EMILIKAN
KETERANGAN
Mandatory/Milik Sendiri
Mandatory/Milik Sendiri
Mandatory/Milik Sendiri
DOKUMEN TENDER NO. GKM...
LAMPIRAN I-B
RENCANA KERJA DAN SYARAT
EMILIKAN
KETERANGAN
Mandatory/Milik Sendiri
Mandatory/Milik Sendiri
Mandatory/Milik Sendiri
Mandatory/Milik Sendiri
Mandatory/Milik Sendiri
DOKUMEN TENDER NO. GKM...
LAMPIRAN I-B
RENCANA KERJA DAN SYARAT
EMILIKAN
KETERANGAN
Mandatory/Milik Sendiri
Mandatory/Milik Sendiri
Mandatory/Milik Sendiri
Mandatory/Milik Sendiri
Mandatory/Milik Sendiri
DOKUMEN TENDER NO. GKM...
LAMPIRAN I-B
RENCANA KERJA DAN SYARAT
EMILIKAN
KETERANGAN
Mandatory/Milik Sendiri
Mandatory/Milik Sendiri
Mandatory/Milik Sendiri
Mandatory/Milik Sendiri
DOKUMEN TENDER NO. GKM...
LAMPIRAN I-B
RENCANA KERJA DAN SYARAT
EMILIKAN
KETERANGAN
Mandatory/Milik Sendiri
Mandatory/Milik Sendiri
Mandatory/Milik Sendiri
Mandatory/Milik Sendiri
Mandatory/Milik Sendiri
Mandatory/Milik Sendiri
Mandatory/Milik Sendiri
Mandatory/Milik Sendiri
DOKUMEN TENDER NO. GKM...
LAMPIRAN I-B
RENCANA KERJA DAN SYARAT
EMILIKAN
KETERANGAN
Mandatory/Milik Sendiri
Mandatory/Milik Sendiri
Mandatory/Milik Sendiri
Mandatory/Milik Sendiri
Mandatory/Milik Sendiri
Mandatory/Milik Sendiri
Mandatory/Milik Sendiri
Mandatory/Milik Sendiri
DOKUMEN TENDER NO. GKM...
LAMPIRAN I-B
RENCANA KERJA DAN SYARAT
EMILIKAN
KETERANGAN
Mandatory/Milik Sendiri
Mandatory/Milik Sendiri
Mandatory/Milik Sendiri
Mandatory/Milik Sendiri
Mandatory/Milik Sendiri
Mandatory/Milik Sendiri
Mandatory/Milik Sendiri
DOKUMEN TENDER NO. GKM...
LAMPIRAN I-B
RENCANA KERJA DAN SYARAT
EMILIKAN
KETERANGAN
DOKUMEN TENDER NO. GKM...
LAMPIRAN I-B
RENCANA KERJA DAN SYARAT
EMILIKAN
KETERANGAN
DOKUMEN TENDER NO. GKM...
LAMPIRAN I-B
RENCANA KERJA DAN SYARAT
EMILIKAN
KETERANGAN
DOKUMEN TENDER NO. GKM...
LAMPIRAN I-B
RENCANA KERJA DAN SYARAT
EMILIKAN
KETERANGAN
Mandatory/Milik Sendiri
Mandatory/Milik Sendiri
DOKUMEN TENDER NO. GKM...
LAMPIRAN I-B
RENCANA KERJA DAN SYARAT
EMILIKAN
KETERANGAN
Mandatory/Milik Sendiri