Professional Documents
Culture Documents
Amendment No 1 To IRC 112 2014 PDF
Amendment No 1 To IRC 112 2014 PDF
Amendment No 1 To IRC 112 2014 PDF
2 6.2.2 Note: (2) Value of εuk shall be taken from the Value of εuk shall be taken as the uniform
Fig.6.2 standard governing the manufacture of elongation given in the standard governing
reinforcement. the manufacture of reinforcement.
3
(Page 30)
10.4.4
(Page 103)
C
The design punching shear resistance The design punching shear resistance shall
(MPa) of slab may be calculated as be assessed at the basic control perimeter,
follows: according to Clause 10.4.2. The design
punching shear resistance (MPa) of slab may
be calculated as follows:
IR
4 15.3.1.2 The minimum cover for post tensioned The minimum cover for post tensioned ducts
ducts shall not be less than maximum shall not be less than 75 mm. Local reduction
(Page 163)
of the outer diameter of ducts or in cover at externally jointed locations of
75 mm. ducts is acceptable.
(local reduction in spacing at
externally jointed locations of ducts is
acceptable).
5 16.9 (1) Deep beams can be designed using Deep beams (span/depth ratio less than 3)
appropriate elastic models or by plastic can be designed using appropriate elastic
(Page 186)
methods. models or by plastic methods.
2. 13.5 Requirements given in this Clause are in Requirements given in this Clause are in
(Page 136) addition to those given in Clause 16.11 addition to those given in Clause 16.14
3. 15.2.6.1 (4) When large bars are used, adequate crack When large bars are used, adequate crack
4.
(Page 159)
15.11
(Page 166)
12.
C
control shall be ensured either by using
surface reinforcement as per Clause
16.2.4.2, or by calculation as per Section
control shall be ensured either by using
surface reinforcement as per Clause
16.5.4 (4), or by calculation as per
Section 12.
fctd (t) is the design tensile strength at time fctd (t) is the design tensile strength at time
of release ‘t’ (Refer Clause 6.4.3.3) taken of release ‘t’ (Refer Clause 6.4.2.3) taken
as 0.7 ftm (t)/γc as 0.7 fctm (t)/γc
IR
5. 16.7.1 (3)
(Page 185) ac < 0.5 hc ac ≤ 0.5 hc
16.7.1 (4)
(Page 185) In corbels with ac > hc In corbels with ac > 0.5 hc
As Amended: