Professional Documents
Culture Documents
Section Viii Allgnment - Procedure: Warning
Section Viii Allgnment - Procedure: Warning
8. \~ e . o: the AC power
8-2. EQUIPMENT REQUIRED. supply (PS-
500-AC), proceed as follows:
1. RF Signal Generator; Hewlett-Packard 9. Befóre turning the transceiver on, co ect
Model 606A or an equivalent signal generator a DC voltmeter to the two jacks on the power
having up to 1 volt output at an impedance of 70 supply (see figure 15), positive to red and
ohm s or less. Throughout the alignment negative 'o blue. Set the voltmeter on a low scale
procedure, unless otherwise specified, the signal (2.5 volts 01' 3.0 volts), There
generator output is unmodulated. a ID-ohm resistor across the tip
16
-