Professional Documents
Culture Documents
C65P1 Spec Sheet - E - A4
C65P1 Spec Sheet - E - A4
com
Single stage high pressure radial blower:
C65P1
62.8 x 65.3x 65.1 mm (2.47 x 2.57 x 2.57 in)
NOTES: - Performances are dependent on the driver used and the test conditions. The data in this spec. sheet was obtained using Boreasa test chamber at 20°C (±2°
C) and sea level, and using a Boreasa D50/5/4Q-E2P driver. It may be different than data measured in other conditions or with other drivers.
- When used as a vacuum, the blower performance might be less then shown herein, depending on the operating point.
- Specifications are subject to change without notice.
- Boreasa blowers have been designed and are manufactured to meet the medical device industry requirements. However, it is not possible to test blowers in
all conceivable customer application configurations. Consequently, to be used in life support equipment, blowers must be life tested and validated by cus-
tomers, in their actual application conditions, in a statistically meaningful quantity.
Technical Data
C65P1-12PS-01 C65P1-18PS-01 C65P1-24PS-01
VCC Nominal Voltage V 12 18 24
VCC Voltage Range V 9 ~ 14 10 ~ 21 10 ~ 28
IN freeblowing @Nom. Volt. mA 6,150 4’080 3’430
IN work. point @Nom. Volt. mA 4,270 2’880 2’410
IN static @Nom. Volt. mA 2,290 1’420 1’090
PN work. point @Nom. Volt. W 51.2 51.8 57.08
LInductance mH 0.006 0.013 0.02
RPhase-Phase Ohm 0.037 0.09 0.15
n freeblowing @Nom. Volt. rpm 44,200 45’200 47’200
n work. point @Nom. Volt. rpm 46,800 47’660 49’700
n static @Nom. Volt. rpm 49,500 50’600 52’300
V freeblowing @Nom. Volt. l/min 480 493 530
V work. point @Nom. Volt. l/min 230 238 249
P work. point @Nom. Volt. Pa 7’850 7’900 8’740
P static @Nom. Volt. Pa 9,250 9’010 9’750
2 2
I Inertia g*mm / oz*in 1450 / 0.0795
M Mass g / oz 180 / 6.35
Life10 (measured in Bi-level mode) hours >18’000*
TOperations °C / °F -20 ~ +60 / -4 ~ +140 (in ice free conditions)
TOperations °C / °F -30 ~ +80 / -22 ~ +176
Leads mm / inch 300 / 11.8 (AWG22)
Connector Molex Microfit 43025-1000 (10 wires)
Housing / Impeller Material Medical grade thermoplastic
Ball Bearing
Tacho
Motor Internal Temperature Sensor
*At given working points and cycle.