Professional Documents
Culture Documents
What Are The Common Causes of Porosity in SA (Submerged Arc) Welds - TWI
What Are The Common Causes of Porosity in SA (Submerged Arc) Welds - TWI
What Are The Common Causes of Porosity in SA (Submerged Arc) Welds - TWI
- TWI
Porosity is a fairly common defect which can be in uenced by many factors. Sometimes it is
clearly visible as pinholes in the weld surface, at other times it is below the surface and is
revealed only by X-ray examination or ultrasonic testing. Unless it is gross or preferentially
aligned, porosity is unlikely to be harmful.
1. Contamination of joint surfaces with oil, paint, grease, hydrated oxides, etc.
These decompose in the arc to give gaseous products which can cause
elongated 'wormhole' porosity often located along the centreline of the weld.
2. Damp ux: ux should be kept dry. It is good practice to dry all uxes before
use and store them in a heated hopper. The manufacturer's recommendations
regarding drying temperatures should be observed. Note that if a ux recovery
unit, driven by compressed air, is used the compressed air should be dried
thoroughly.
https://www.twi-global.com/technical-knowledge/faqs/faq-what-are-the-common-causes-of-porosity-in-sa-submerged-arc-welds 1/3
9/4/2020 What are the common causes of porosity in SA (Submerged Arc) welds? - TWI
3. Insu cient ux burden can expose the arc and molten weld pool to
atmospheric contamination.
The surface of a weld may sometimes contain small depressions known as surface pocking
or gas ats. These are harmless and while the exact cause is not fully understood it is linked
to conditions which cause generation of gas or make it di cult for gas to escape; for
example, moisture or lack of deoxidants and too many nes in the ux to allow gas to pass
readily.
contactus@twi.co.uk
+44(0)1223 899000
contactus@twi.co.uk
https://www.twi-global.com/technical-knowledge/faqs/faq-what-are-the-common-causes-of-porosity-in-sa-submerged-arc-welds 2/3
9/4/2020 What are the common causes of porosity in SA (Submerged Arc) welds? - TWI
https://www.twi-global.com/technical-knowledge/faqs/faq-what-are-the-common-causes-of-porosity-in-sa-submerged-arc-welds 3/3