Professional Documents
Culture Documents
DCT P0113 Codigo de Falla Avenger
DCT P0113 Codigo de Falla Avenger
4L 4302
- Verify that there is good pin to terminal contact in the Intake Air Temperature Sensor and Powertrain Control Module connectors. Replace
the IAT Sensor if no problems were found in the connectors.
- Perform the PCM Verification Test.See: Verification Tests/Powertrain Verification Test
No
- Go to 6
Yes
- Repair as necessary.
- Perform the PCM Verification Test.See: Verification Tests/Powertrain Verification Test
No
GPEC
P0113-INTAKE AIR TEMPERATURE SENSOR CIRCUIT HIGH
Dodge Avenger L4-2.4L 4303
- When Monitored:
With the ignition on and battery voltage greater than 10.4 volts.
- Set Condition:
The PCM detects that the Intake Air Temperature Sensor input voltage is above the maximum acceptable value.
Dodge Avenger L4-2.4L 4304
Always perform the Pre-Diagnostic Troubleshooting procedure before proceeding.See: Powertrain Management/Computers and Control
Systems/Testing and Inspection/Initial Inspection and Diagnostic Overview
Diagnostic Test
1. DTC IS ACTIVE
Start the engine and allow it to reach normal operating temperature.
WARNING: When the engine is operating, do not stand in direct line with the fan. Do not put your hands near the pulleys, belts, or fan.
Do not wear loose clothing. Failure to follow these instructions can result in personal injury or death.
Yes
- Go to 2
No
- Refer to the *CHECKING FOR AN INTERMITTENT DTC Diagnostic Procedure.See: Powertrain Management/Computers and Control
Systems/Testing and Inspection/Symptom Related Diagnostic Procedures/Checking For An Intermittent DTC
Yes
No
Dodge Avenger L4-2.4L 4305
- Go to 3
NOTE: When checking circuits at the Powertrain Control Module (PCM), be careful not to damage or distort the connector terminals.
Improper measurement technique could result in poor pin to terminal contact.
Measure the resistance of the (K21) IAT Signal circuit between the Intake Air Temperature Sensor harness connector and the Powertrain Control
Module (PCM) harness connector.
Is the resistance below 5.0 ohms?
Yes
- Go to 4
No
- Repair the (K21) IAT Signal circuit for an open circuit or high resistance.
- Perform the PCM Verification Test Ver. 1See: Verification Tests/Powertrain Verification Test.
NOTE: When checking circuits at the Powertrain Control Module (PCM), be careful not to damage or distort the connector terminals.
Improper measurement technique could result in poor pin to terminal contact.
Measure the resistance of the (K900) Sensor Ground circuit between the Intake Air Temperature Sensor harness connector and the Powertrain
Control Module (PCM) harness connector.
Is the resistance below 5.0 ohms?
Yes
- Go to 5
No
- Repair the (K900) Sensor Ground circuit for an open circuit or high resistance.
- Perform the PCM Verification Test Ver. 1See: Verification Tests/Powertrain Verification Test.
Yes
- Go to 6
No
- Go to 7
Yes
- Repair as necessary.
- Perform the PCM Verification Test Ver. 1See: Verification Tests/Powertrain Verification Test.
No
Yes
- Repair as necessary.
- Perform the PCM Verification Test Ver. 1See: Verification Tests/Powertrain Verification Test.
Dodge Avenger L4-2.4L 4308
No
NGC
P0113-INTAKE AIR TEMPERATURE SENSOR 1 CIRCUIT HIGH