Professional Documents
Culture Documents
Creating Details: 1. Start Revit 2018
Creating Details: 1. Start Revit 2018
Creating Details
Exercise 13-2
1. Start Revit 2018
6. Draw a line 1000mm from the middle point of the top horizontal line, then offset
the line to the right and left by 300. Delete the first line
7. Using the end of the right vertical line, draw a slanted line 500mm (angle = 45o),
then draw a horizontal line 1500mm
9. Using Trim/Extend to Corner link the top horizontal line with the left vertical line
13-17
Revit Structure 2018 Essentials
11. Using Annotate tab, Detail panel, Filled Region, from Type selector, select
Concrete, and specify the rectangle of the footing, click ( ) to finish the
command
13. Using Annotate tab, Detail panel, Component / Detail Component, from Type
selector, select M_Rough Cut Lumber-Section 75 x 400, use spacebar to
rotate, and insert it at the bottom of the two vertical lines
14. Using Annotate tab, Detail panel, Component / Detail Component, from Type
selector, select M_Anchor Bolts Hook-Side M36, and insert it at the top of the
lumber section. Select it; from Properties set Length=500mm. Make the
necessary adjustment. Select it again, from context tab, select Send to Back
13-18
Chapter 13: Tagging, and Detailing
16. We want to add a region using Solid Gray from the top of the footing, up to the
lumber section with width = 10 to identify it look at the picture below:
17. Using Annotate tab, Detail panel, Component / Repeating Detail Component,
from Type selector, click Edit Type, using Detail make sure that the selected
detail is M_Concrete Block : 200 x 150mm Nominal
18. From top to bottom, add the repeating detail, even if it gets inside the isolated
footing. Select it, and from context tab, click Send to Back
13-19
Revit Structure 2018 Essentials
20. Using Annotate tab, Detail panel, Insulation, from Properties, set the Insulation
Width = 400mm. Locate the midpoint between the two vertical line, and add the
insulation from top to bottom
21. Using Annotate tab, Detail panel, Component / Detail Component, from Type
selector, select M_Break Line, use spacebar to rotate, and insert it as shown
below making the necessary adjustment:
13-20
Chapter 13: Tagging, and Detailing
23. From Project Browser, right click the name of the view, and select Save to New
File option, and save the file inside the Exercise folder
25. Go to Inset panel, locate Import panel, select Insert From File button, and
locate Insert Views From File, locate the file you just saved
26. Select the view you want. You will see that a new Drafting View was added in
your new project
13-21