POLITESKni<
‘DJM 3052 INDUSTRIAL ELECTRONIC
PRACTICAL WORK 2B — JUNE 2020
(Clo 2:pq)
Please submit pages 2 to 5 for lecturer verification.
TITLE RELAY CONTROL CIRCUIT
NAME MUHAMMAD IRFAN iN SHAH Higa
MATRICNUM. : Ay peng F tole pes ee
PROCEDURE B: DC TO AC SWITCHING CONTROL CIRCUIT
‘Step 1: List all the component and its function in Table 1
Component Function
OV Battery that stores chemical energy and converts it to elecirical energy. |
ie Switch The switch is a mechanical, electrical or electronic device that opens or
closes a circuit.
Resistor |A passive two-terminal electrical component that implements electrical
esistance as a circuit element
‘Capacitor Passive two-terminal electrical component used to store a
rey electrostatically in an electric field |
Diode
locking it in the opposite direction.
Transistor NPN fos is a semiconductor device used to amplify or switch electronic
fom and electrical power.
Relay SPDT relay is an electrically operated switch. Current flowing through the coil
| if the relay creates a magnetic field which attracts a lever and changes the
switch contacts
Filament Lamp ip will heats up when an electric current passes through it, and
po as aresult
AC Voltage Source block represents an ideal voltage souree that
Cl eae faa ies ecial voltage across ts output terminals, independent ofthe
flowing through the source. E :
=I
as (10 marks)
Scanned with CamScanner>, :
Step 2: Attach the relay control circuit connection as on the Livewire in simulation mode. Record and
explain its operation in the stated condition:
When SW1
‘open contact
(5 marks)
When SW1
close contact
(6 marks)
Scanned with CamScannerPOLITESXnilx<
—™
A——
Step 3: Explain your observation regarding the circ
operation.
Your explanation about the operation of the circuit by including the following items:
a. The current flow in the circuit
b. The voltage drop in the circuit
Output circuit
d. The use of relay in the speci
circuit
Based on circurt the coment wilh
Pip thee Grey} when
the Suite fs in normally
Close The Current als Plow _thvaegh
the veleg Corl. Then, He velay ait will en and it ated
the Com termina! to No Contact. Ut is beause the relay
Coil get coyvent Prom Ac voltoqe Source and the flux
force _ta__change Com contact and connected _fo__Na
Centact,
The voltage trl ner wher Switch C.Swt)
ison
ond if will Sloaly doe ty Om Wis Wwecayse the AC
Vdtoge Source _entigired _ Corvent three all cireyit then _Yelay
col is at Ho conket. The lamp will on for a Pew Steonel
depend on tht _value_of _esistar ane cafacrtoy. + will _hagpen
if the relay conl_iS on NG Contact. When we change the
valve
of resistor, the lamp will on / blinking on _ different
time,
Lastly the use of relay js te turn onthe __anotlyr _Citcurt
thot uses the Ac Voltage Source _40_Control __the _Qurent -
(6 marks)
Scanned with CamScannerPOLITERNIH
MALAYSIA
CONCLUSION (relate the objective and outcome of all circuits)
Conclusion, we Mave lecrned how riley operated in the