Professional Documents
Culture Documents
MCQ Fso Iii, Iv, V PDF
MCQ Fso Iii, Iv, V PDF
MCQ Fso Iii, Iv, V PDF
1. Which of the following gives the work required for size reduction of coal to 200 mesh in a ball mill
most accurately?
a) Rittinger’s law
b) Bonds law
c) Kicks law
d) None of these above ANS.. a
5. Sphericity of cubical practical, when its equivalent diameter is taken as the height of the cube, is
a) 0.5
b) 1
c) √2
d) √3 ANS…b
7. Rittingers number which designates the new surface produced per unit mass of mechanical energy
absorbed by the material being crushed, depends on the
a) State or manner of application of crushing force
b) Ultimate strength of the material
c) Elastic constant of the material
d) All the above ANS…d
8. In case of plate and frame filter press, filtrate flow through the cake follows __________ flow
a) Plug
b) Turbulent
c) Laminar
d) None of these above ANS…b
11. Percentage of drum submerged in the slurry in case of rotary drum filter is
a) 3
b) 30
c) 85
d) 25 ANS…b
12. In forth floatation, chemical agent added to cause air adherence is called
a) Collector
b) Frother
c) Modifier
d) Activator ANS…a
14. Size reduction of the __________ can be suitably done by ball mills, crushing roll and rod mills.
a) Metalliferrous ores
b) Non-metallic ores
c) Basic slags
d) Asbestos & mica
15. In a mixer the quantity (v. L/D) is termed as ____________ number (where v- longitudinal velocity
of the material, L- length of the mixer, D- diffusivity in axial mixing)
a) Weber
b) Peclet
c) Brinkman
d) Schmidt
16. ________ mixer is used for devulcanisation of rubber scarp, and making water dispersion and rubber
solution
a) Tumbler
b) Banbery
c) Muller
d) Rubbon blender
20. During washing of filter at the end of constant pressure filtration, the rate of washing equals the rate
of filtration
a. At time zero
b. At the end of filtration
c. When half the filtrate has been obtained
d. At the end of filtration, but decreases with time subsequently
22. A __________ employs a set of screen across a flow channel for the separation of dirt/rust from a
flowing liquid stream.
a) Thickener
b) Classifier
c) Strainer
d) Clarifier
23. The most efficient equipment for the removal of sub-micronic dust particles from blast furnace gas is
the
a) Venturi atomiser
b) Gravity settling chamber
c) Electro-static precipitator
d) Cyclone separator
24. The specific cake resistance for compressible sludges is a function of the pressure drop
a) Over cake
b) Over medium
c) Overall
d) None of these
25. __________ balls capable of grinding the feed in a ball mill gives the maximum efficiency.
a) Cast iron
b) Minimum size
c) Maximum size
d) Elliptical