Professional Documents
Culture Documents
Ub 8000 PDF
Ub 8000 PDF
Dimensions
Caution
We strongly recommend that all neptronic® products be wired to a separate transformer and that transformer shall service only neptronic® products. This precaution will
prevent interference with, and/or possible damage to incompatible equipment.
When multiple actuators are wired on a single transformer, polarity must be observed. Long wiring runs create voltage drop which may affect the actuator performance.
UT-WT/060412 1
UT000/020/010/030
WT000/020/010/030 Specification & Installation instruction
Exploded view
Wiring Diagrams
4 wire / 2 position (ON-OFF) 5 wire / 3 point floating
1 2 3 4 5 6 1 2 3 4 5 6
FEEDBACK
FEEDBACK COMMON (-) 4 to 20 mA
COMMON (-) 4 to 20 mA CONTROL SIGNAL
SUPPLY (+) SUPPLY (+)
SUPPLY DRIVE CCW
CONTROL SIGNAL CONTROL SIGNAL CONTROL SIGNAL CONTROL SIGNAL
COMMON SUPPLY DRIVE CW COMMON SUPPLY DRIVE CW
PC Board
Dip switch settings
Potentiometer
UB8000 SERIES
Rotation: CCW
Fail safe return at 110º
Not used
ON ON
Dip swith Cluth
ON
1 2 3 1 2 3
1 2 3
Rotation: CW
LED
Terminal Fail safe return at 0º
JP5
+ - JP4 1 2 3 4 5 6
Battery terminal
Only on model 010 & 030
Stroke adjustment
To adjust the stroke, press and release the reset button to start the auto-stroke process.
The LED should be illuminated.
• First option:
The actuator will then travel in both directions to find it's limit.
The LED will extinguish, the process is complete.
• Second option:
When the desired end position is reached, press and release the reset button. The actuator will now return back to its
original position. (you can also press and release the reset button when It's reaches the original position)
The LED will extinguish, the process is complete.