EC I Unit Test 3

You might also like

Download as docx, pdf, or txt
Download as docx, pdf, or txt
You are on page 1of 3

DEPARTMENT OF ELECTRONICS AND COMMUNICATION ENGINEERING

UNIT TEST –I / II / III /IV/V


ACADEMIC YEAR 2018-2019-ODD SEMESTER

Sub. Code &Name: EC8351– ELECTRONIC CIRCUITS I Date: 04/09/2018


Year/branch/section: II-ECE Session &Duration: FN &1hr 30 min.
Semester: 03 Max. Mark 50
PART A (6×2=12)
(Answer all Questions)
1. State body effect. (R)
2 Sketch the small signal model of JFET.(A)
3. List the difference of BJT and MOSFET.(R)
4. Argue N channel FET is preferred over P Channel FET.(E)
5. Examine the trans conductance of a JFET if its amplification factor is 96 and drain resistance is 32 KΩ(AN)
6. List the difference of CS, CD, and CG amplifier. (R)

PART B (2×12=24)
(ANSWER ALL QUESTIONS “EITHER” OR “TYPE”)
7. a) Discuss in detail about the small signal analysis of common source amplifier with un bypassed (12) (U)
capacitor.
(OR)
b) Construct BICMOS amplifier and investigate Transconductance, advantages and different types of (12) (C)
BICMOS amplifier.

8 a) Test small signal model of common gate amplifier and find out gain, input and output impedances. (12) AN)

(OR)
b) Sketch the circuit diagram and explain the small signal analysis of source follower Amplifier. (12) (A)

PART C (1×14=14)

(ANSWER ALL QUESTIONS “EITHER” OR “TYPE”)


(14)(C)
9. a) Formulate the common gate amplifier as shown in figure gm = 2.8 ms and λ =0, and calculate input
impedance, output impedance and voltage gain.

(OR)
9. b) Experiment the circuit shown in figure and evaluate the small signal voltage gain. (14)(AN)

Prepared By HOD
[P.MANOJ]
Students will be able to design various biasing circuits for all the
EC8351.1
type of transistors to keep the operating point Stable .
EC8351.2 Students will be able to design and analyze the small signal
equivalent circuits of BJT Amplifiers
EC8351.3 Students will be able to design and analyze the small signal
equivalent circuits of FET Amplifiers
EC8351.4 Students will be able to design and analyze the Frequency
Response of Amplifiers
EC8351.5 Students will be able to design and analyze the different types of
power supplies
EC8351.6 Students will be able to troubleshoot and fault analysis of power
supplies.

Levels : Understanding – U, Remembering – R, Applying – A,


Analysis-AN, E- Evaluate, C- Create

Cos / Marks in
EC8351.3 Marks
Level percentage
R 1,3,6 6
20%
U 7a 12
A 2,8b, 14
48%
AN 5,8a,9b 28

E 4 2
32%
C 7b,9a 26
Marks 88

You might also like