55th BMA Special Course Priliminary Question - 14 - Aug - 2020 - Signal (EEE, ECE, EECE)

You might also like

Download as pdf or txt
Download as pdf or txt
You are on page 1of 3

55th BMA SPL COURSE-SIGNALS (EEE/EECE/ECE)

Preliminary Written Exam (EEE): Full marks: 100


• No negative marking

• No Competition, pass or fail (Pass Mark:40)


• This question for Signal- EEE/ECE/EECE. Keep in mind that, Signal-CSE has different

question set.
• Time: 1 hour (You have to carry your own watch, if you want keep pace with time)

• The marking of subjective part is approximate (It’s really tough to remember the
marks distribution! Isn’t it?)

1-20. True/ False: 20

1) By using current divider rule, we can determine current of any branch of series-parallel circuit.
2) In AC circuit, the impedance of a capacitor increase with frequency (kind of this)

3) For maximum power transfer, the inductance and capacitance have to be complex
conjugate.

4) In high pass filter, the output voltage is taken across the resistor
5) A band stop filter passes signal between it’s lower and upper side cut-off frequency

6) Transformer coupled rectifier is good because ……………


7) To perform basic comparator operation between two inputs, XOR is used.

8) The advantage of FM over AM is ……………


21-40. MCQ: 20

21. Which quantity is measured by multimeter?

22. In n-channel JFET, the gate is which type?


23.In push-pull circuit, each transistor conducts which angle portion? (0 to 180/greater than

180/……………/……………)
24. CMOS is used instead of relay. Why? (Speed/Size/……………/ All of these reason)

25. Most Gain in which amplifier? (A/B/C/AB)


26. To encode 8 different states, how many control bits are needed?

27. If dynamo meter type wattmeter is used, it gives which quantity? (V/A/…………./V and A)
28. If the area of a parallel plate capacitor is increased, which will increase?

(Capacitance/……………/……………/ The voltage which it can withstand with)


29. E.M.F. comparison by using potentiometer is better than galvanometer based method,

because-(It doesn’t take the load/ It takes the load/……………/……………)


30. A sine signal is the input of a capacitive circuit, if the frequency increases, which will happen?

(V increase/I decrease/I increase/……………)


31. To protect capacitor of a ..………….(most probably rectifier) which should be used? (surge

capacitor/surge inductor/……………/……………)
32. There was only one MCQ from electromagnetism.
41-50 Subjective: 60

41. Write the properties of an ideal op amp. 5


42. Find the equivalent resistance and voltage drop across each resistor of the following 10

circuit:

43. Write down the differences between AM and FM. 6


44. A 25-KVA, single phase transformer has 250 turns on the primary and 40 turns on the

8 secondary winding. The primary is connected to 1500 volts 50Hz mains. Calculate:
a) Primary and secondary full load currents.

b) Secondary E.M.F.

c) Maximum flux in the core.


45. Implement a NAND gate using NOR gate. 6

46. What are the layers of OSI model? Describe each layer (kind of like this). 7
47. What are the advantages of negative feedback although it reduces the output? (kind of 5

like this).
48. Draw the circuit diagram and input-output waveform of a bridge rectifier. 5

49. What are the advantages of optical fiber over copper media? 4
50. In the calculation of real transformer, which losses should be include to make the 4
transformer model accurate?

You might also like