Professional Documents
Culture Documents
CAS AP Series Span PDF
CAS AP Series Span PDF
CAS AP Series Span PDF
1. Make sure scale is UNPLUGGED. Remove the CALIBRATION BOLT located on the rear left side of the scale.
2. After removing the CALIBRATION BOLT you will see a red MICRO-SWITCH. Slide the MICRO SWITCH to the
left (towards pole).
4. Plug scale in. The WEIGHT display should flash “CAL” three times and then go blank.
6. Once the displays read “LoAd” put the FULL CAPACITY OF WEIGHT (30 lb or 15 lb) on the platter and press
the C key.
FULL CAPACITY OF WEIGHT is either 15lb(6 kg) or 30lb(15 kg) depending on whether your scale is set up for pounds
or kilos.
7. Once the scale displays go blank, remove all weights from the platter.
10. Unplug the scale and slide the MICRO SWITCH to the right (away from pole) and replace the CALIBRATION
BOLT located on the rear left side of the scale.
A) If scale is NOT 100% accurate, unplug scale and repeat steps 1 to 11.