Professional Documents
Culture Documents
Lte Kpi PDF
Lte Kpi PDF
Accessibility KPI
Retainability KPI
Mobility
KPI
Integrity
KPI
Availability
KPI
Utilization
KPI
ACCESSIBILITY KPI:
☰ RRC Setup Success Rate
RRC setup success rate is calculated based on the counter at the eNodeB when the eNodeB
received the RRC connection request from UE. Number of RRC connection attempt is collected
by the eNodeB to the measurement at point A, and the number of successful RRC connection
calculated at point C. Here's an illustration:
☰ Call Drop
VoIP call drop arise when VoIP ERAB release is not normal. Each ERAB associated with QoS
information. Here's an illustration of two procedures being done to release ERAB namely: ERAB
release indication and the UE context release request:
MOBILITY KPI:
Handover attempt occurs at point B, when the source ENodeB (S-eNodeB) sends RRC
connection reconfiguration message to the UE. He decided to conduct inter ENodeB HO. in this
KPI, the source and the target cell work on the same frequency. The number of the attempt HO
calculated at the source cell. The number of successful HO occurs at point C. During HO, HO
amount which success is measured in the cell souce. This measurement appears typing S-
eNodeB received a UE context release message from the target eNode B (T-eNodeB), or the UE
context release command from the MME, which shows that the UE-eNodeB T has successfully
attach at the T-eNodeB.
The following scenarios illustrate intra frequency B HO - inter ENodeB:
Following the definition of Intra Frequency Out Handover Success Rate KPI:
INTEGRITY KPI:
☰ E-UTRAN IP Throughput
A KPI that shows how E-UTRAN impacts the service quality provided to an end-user.
Payload data volume on IP level per elapsed time unit on the Uu interface. IP Throughput for a
single QCI:
To achieve a throughput measurement that is independent of bursty traffic pattern, it is important
to make sure that idle gaps between incoming data is not included in the measurements. That
shall be done as considering each burst of data as one sample. ThpVolDl is the volume on IP
level and the ThpTimeDl is the time elapsed on Uu for transmission of the volume included in
ThpVolDl.
☰ E-UTRAN IP Latency
A measurement that shows how E-UTRAN impacts on the delay experienced by an end-user.
Time from reception of IP packet to transmission of first packet over the Uu.
To achieve a delay measurement that is independent of IP data block size only the first packet
sent to Uu is measured.
To find the delay for a certain packet size the IP Throughput measure can be used together with
IP Latency (after the first block on the Uu, the remaining time of the packet can be calculated
with the IP Throughput measure).
T_Lat is defined as the time between receiption of IP packet and the time when the eNodeB
transmits the first block to Uu.
Since services can be mapped towards different kind of E-RABs, the Latency measure shall be
available per QoS group.
AVAILABILITY KPI:
As for defining the cell as available, it shall be considered available when the eNodeB can
provide E-RAB service in the cell.
UTILIZATION KPI:
The mean number of simultaneous online and answered sessions together with maximum
number of sessions provided by network can reflect system resource utilization. If the value of
this KPI is very high, it indicates system capacity is not enough, and needs to be increased. This
KPI is focusing on network view.