This document provides a test method for qualifying ferrite cores. It outlines verifying the approved manufacturer and material grade, measuring dimensions and inductance values, and performing a visual inspection to check for defects like cracks, chips or burrs. Cores must meet specifications for manufacturer, material properties, dimensions, AL value from inductance measurement, and pass visual inspection to be qualified.
This document provides a test method for qualifying ferrite cores. It outlines verifying the approved manufacturer and material grade, measuring dimensions and inductance values, and performing a visual inspection to check for defects like cracks, chips or burrs. Cores must meet specifications for manufacturer, material properties, dimensions, AL value from inductance measurement, and pass visual inspection to be qualified.
This document provides a test method for qualifying ferrite cores. It outlines verifying the approved manufacturer and material grade, measuring dimensions and inductance values, and performing a visual inspection to check for defects like cracks, chips or burrs. Cores must meet specifications for manufacturer, material properties, dimensions, AL value from inductance measurement, and pass visual inspection to be qualified.
This document provides a test method for qualifying ferrite cores. It outlines verifying the approved manufacturer and material grade, measuring dimensions and inductance values, and performing a visual inspection to check for defects like cracks, chips or burrs. Cores must meet specifications for manufacturer, material properties, dimensions, AL value from inductance measurement, and pass visual inspection to be qualified.
REFERENCE: Nil DEFINITIONS: Nil RESPONSIBILITY: IQC team 1. APPROVED MANUFACTURER: Material part number shall be entered in TPS programme (DOS KT system) and the approval of manufacturer to be conformed through Bill of material (BOM). 2. MATERIAL GRADE VERIFICATION: Material grade shall be verified through printing on the core or test report or on material or packaging or supplier datasheet/catalogue. 3. DIMENSIONS: Dimensions shall be as per respective drawing / supplier data sheet / catalogue. Suitable instrument (Digital vernier, Micrometer, Scale, Micro Vu) can be used for measurement. 4. AL VALUE / INDUCTANCE CHECK: Core halves to be assembled in 100turns coil and inductance shall be measured using LCR meter. AL value to be calculated using the below formula. AL value in nH = Inductance / Turns2 5. VISUAL INSPECTION: There shall be no chip-off and damages. There shall be no cracks. There shall be no burrs on edges. The appearance shall be good.