Professional Documents
Culture Documents
0600 Chow Kit Hotel Kuala Lumpur: Equipment Specification Issue 01 03.08.18
0600 Chow Kit Hotel Kuala Lumpur: Equipment Specification Issue 01 03.08.18
0600 Chow Kit Hotel Kuala Lumpur: Equipment Specification Issue 01 03.08.18
ISSUE 01
03.08.18
0600 Chow Kit KL
Issue 01
Preliminaries
• The pre-commissioning phase is crucial in establishing with the construction and design team, the elements of the installation that are interfacing correctly and incorrectly,
both architecturally and electrically, in order to highlight any snagging and identify changes to be carried out.
• The final commissioning of the project can only take place when all snagging items established during the pre-commissioning phase have been closed.
• To verify that all luminaires and associated components have been installed according to the relevant Manufacturer’s recommendations, and to EQ2Light drawings, details,
and specifications.
• To verify that the Lighting Control System has been installed and cabled according to the relevant Manufacturer’s recommendations.
• To make EQ2Light aware of any site condition concerning the lighting installation that varies from the drawn information and design intent.
• To ensure, where specified luminaires are to be used as part of the temporary site illumination, that said luminaires are fully cleaned and relamped prior to commissioning
and handover of the site to the owner.
• The make available adequate personnel, including at least one electrician, and all necessary access equipment is provided for any focusing and scene setting, as is required at
the commissioning of the installation.
LIGHTING CONTROL MANUFACTURER’S OBLIGATIONS PRIOR TO AND DURING PRE-COMMISSIONING & COMMISSIONING:
Issue 01
Preliminaries
SPECIFICATION NOTES:
• All control gear/transformer/driver/ballast/power supplies to be manufactured in accordance with the relevant British Standards or local prevailing regulations.
• EQ2Light recommends the use of transformers with a secondary supply voltage of 95%.
• All control gear/transformer/driver/ballast/power supplies and emergency battery packs for ceiling recessed luminaires are to be accessed through the ceiling cut-out unless
stated otherwise in the specification.
• All emergency lighting equipment is to be suitable for 3 hours, maintained operation unless stated otherwise.
• This specification is to be read in conjunction with all issued information by EQ2Light, including but not limited to, the control schedule and drawing information.
• This specification is equal or approved. Alternative luminaires must be approved by EQ2Light.
• Where supplied, costings are based on information available at the time of issue, are not inclusive of cabling, installation, delivery, or third party overhead and profit, and are
to be used as a guide only.
• All white light sources have a colour rendering index CRI (Ra) ≥ 80.
LV – Low Voltage
LED - Light Emitting Diode
LEDL - LED Linear
HID – Metal Halide / Sodium
FL – Linear Fluorescent
CC – Cold Cathode
CF – Compact Fluorescent
TH – Tungsten Halogen
T – Tungsten
PHASE DIM – Leading/Trailing Edge
DSI – Digital Serial Interface
DALI – Digital Addressable Lighting Interface
DMX – Digital Multiplexing
RDM – Remote Device Management
PIR – Passive Infrared or Occupation/Vacancy Detector
0600 Chow Kit KL
Issue 01
LAMP
LAMP LAMP LAMP LUMINAIRE CONTROL
REF: DESCRIPTION: MANUFACTURER: PRODUCT CODE: IP RATING FINISH LAMP CCT LOAD
TYPE: BASE SPEC: LUMENS: PROTOCOL:
(WATTS):
A High output LED strip within angled OSRAM LF2000-G3-830-04 IP20 Opal LEDL Integral 3000K LED 15 2000lm DIMMABLE
aluminium profile and opal cover. Beam Profile: LF-LTS-2100
angle: 120 degrees. Strip dimensions: L Cover: LF-LTS-COVER-S
4500 mm x W 8mm x H 1,4mm. Overall Driver: to be confirmed once the
dimensions: W 18mm x H 17mm. control protocol is confirmed
To be ordered and supplied with all
necessary accessories. All lengths to be
confirmed on site prior to order.
Note: depending on wires cross sections,
the 80W DALI driver can be located up to
45m away from the luminaire.
B Decorative pendant to lobby lounge by DELIGHTING L-102 IP20 Brass/Milk LED TBC 2700K- LED DIMMABLE
interior designer Glass 3000K
C Decorative pendant to meeting room by DELIGHTING L-201 IP20 Brass/Ivory LED TBC 2700K- LED DIMMABLE
interior designer Fabric 3000K
D Decorative pendant to bar counter by DELIGHTING TBC IP20 TBC LED TBC 2700K- LED DIMMABLE
interior designer 3000K
F Recessed round downlight in die-cast LUMZ Aurora DL-04H-J-W18-30-WH IP44 White LED 3000K LED 18 ±385lm DIMMABLE
aluminium. Medium beam output: 25
degrees. Dimensions: D 112mm, H 135mm.
Cut-out 105mm. Connected to remote
dimmable driver.
G Diffused LED strip connected to remote OSRAM LFD800T-G1-830-06 IP67 Opal LEDL Integral 3000K LED 11.5 750lm DIMMABLE
dimmable driver. Beam angle 120 degrees. Driver: to be confirmed once the
Dimension: L6000 mm x H11mm x W14mm. control protocol is confirmed
To be ordered and supplied with all
necessary accessories. All lengths to be
confirmed on site prior to order.
Note: depending on wires cross sections,
the 80W DALI driver can be located up to
45m away from the luminaire.
H Decorative wall light to restaurant and lobby DELIGHTING L-202 IP20 Brass/ LED TBC 2700K- LED DIMMABLE
by interior designer Alabaster 3000K
J Decorative table lamp to reception desk and DELIGHTING L-105 IP20 Brass LED TBC 2700K- LED SWITCHED
lobby by interior designer 3000K
K Decorative table or floor lamp to lobby DELIGHTING L-106 IP20 TBC LED TBC 2700K- LED SWITCHED
lounge by interior designer 3000K
0600 Chow Kit KL
Issue 01
L Recessed round downlight in die-cast LUMZ Olympus DL-14C-J-W7-30-BL IP44 Black LED Integral 3000K LED 12 ±180lm DIMMABLE
aluminium. Narrow beam output: 25 *Code to be confirmed for narrow
degrees. Dimensions: D 96mm, H 41mm. 15 degree beam optic
Connected to remote dimmable driver.
M Decorative ceiling light to circulation areas DELIGHTING L-404 IP20 Brass/Milk LED TBC 2700K- LED DIMMABLE
by interior designer Glass 3000K
N Decorative pendant to double height space DELIGHTING L-103 IP20 Brass/Ivory LED TBC 2700K- LED DIMMABLE
by interior designer Fabric 3000K
P High output LED strip within angled OSRAM LF2000-G3-830-04 IP20 Opal LEDL Integral 3000K LED 15 2000lm DIMMABLE
aluminium profile and opal cover. Beam Profile: FX-QMS-G1-TU16H12LS-
angle: 120 degrees. Strip dimensions: L 300
4500 mm x W 8mm x H 1,4mm. Overall Cover: FX-QMS-G1-CLT-300
dimensions: W 16mm x H 18mm. Driver: to be confirmed once the
To be ordered and supplied with all control protocol is confirmed
necessary accessories. All lengths to be
confirmed on site prior to order.
Note: depending on wires cross sections,
the 80W DALI driver can be located up to
45m away from the luminaire.
R Decorative table lamp to meeting rooms by DELIGHTING L-403 IP20 TBC LED TBC 2700K- LED SWITCHED
interior designer 3000K
S Decorative table lamp to meeting rooms by NEOZ / DELIGHTING L-107 IP20 Brass LED Integral 2700K LED 1 60+ lm BATTERY
interior designer
XA Wall mounted external luminaire with LUMZ LED UDL 114 V2 IP65 Dark Grey LED Integral 3000K LED 28 2460lm DIMMABLE
symmetric uplight and downlight WL-25A-JW28-30-DG
components. Dimensions: D 114mm x W
155mm x H 288mm. Mounting bracket: W
88mm x H 114mm. Integral dimmable
driver.
XA Inground adjustable round luminaire with IGUZZINI E125 IP68 Steel LED Integral 3000K LED 8.8W 504lm DIMMABLE
OP2 narrow beam. Dimensions: D 144mm x
H147mm. To be connected to remote
dimmable driver.
XB Decorative ceiling light to external DELIGHTING L-502 IP44+ TBC LED TBC 3000K LED DIMMABLE
circulation areas by interior designer.
Suitable for outdoor use
XC Spiked miniature LED projector suitable for LUMZ LED SP 76 V2 IP65 Black LED Integral 3000K LED 9 650lm DIMMABLE
outdoor use. Dimensions: D 76mm x H SL-10A-J-W9-30-BL
195mm. Narrow beam: 20 degree. SP 76 Spike SA 0006-BL
Connected to remote driver.
XD Wall mounted external luminaire with LUMZ LED SM 114 V2 IP65 Dark Grey LED Integral 3000K LED 14 1230lm DIMMABLE
symmetric uplight components. Dimensions: WL-26A-J-W14-30-DG
D 114mm x W 155mm x H 155mm.
Mounting bracket: W 80mm x H 114mm.
Integral dimmable driver.
0600 Chow Kit KL
Issue 01
Document Control
Issues
Revision History
Issue 01
Contacts