Professional Documents
Culture Documents
40 Litre Electric Cool Box: Item Code
40 Litre Electric Cool Box: Item Code
ITEM CODE-237466
TO OPERATE
2. If the unit is operated continuously, it will lower the temperature inside to about 16°C below that of
the surrounding air.
3. The best performance will be obtained if the unit is loaded with food and drinks that are already
cold.
4. For best cold retention after disconnection, keep the lid tightly closed.
ADVICE
2. Shade the unit from direct sunlight and leave windows slightly open to allow for air circulation.
3. The unit is designed for operation in vehicles with a negative earth. If your vehicle has a positive
earth terminal, a competent electrician must rewire the cigarette lighter end of the adaptor.
5. Performance will be impaired by the addition of any substantial amount of items at room
temperature.
6. When not in use the unit must be stored open to prevent mould growth.
7. NEVER fill the unit with water. DO NOT immerse the unit in water.
8. Always disconnect the unit from electricity for cleaning. Wipe clean using a mild detergent solution.
9. Disconnect the unit while the vehicle motor stop working otherwise the power in the cell might be
off.
TROUBLESHOOTING
If the unit does not appear to function correctly, unplug the unit and check the following:
Your cooler does not function There is no voltage flowing The ignition must be switched on
(DC plug is inserted, LED on from the 12V socket in most vehicles for voltage to
the plug does not glow). (cigarette lighter) in your vehicle. flow at the cigarette lighter.
Your cooler does not function No voltage present in the AC Try using another plug socket.
(AC plug is inserted). voltage socket.
Your cooler does not cool The inner fan or the cooling This can only be repaired by an
(plug is inserted, LED on the element is defective. authorized customer services
DC plug glows). unit.
The fuse of the 12V plug has Replace the fuse (8A) in the 12V
blown. plug.(unscrew the tip)
There is water inside the cooler Moisture in the air, trapped This is not a product fault, the
inside the cooler, is condensed inner of the cooler is not
by the low temperature. ventilated. Dry the condense
water periodically.
There is ice formation near the Moisture in the air, trapped This is not a product fault.
inner ventilator inside the cooler, is condensed Switch the unit off and let the
to water and freezes in contact ice melt, remove gently, check
with the ventilator. Ice formation the unit periodically if it is used
can block the ventilator and continuously.
damage the unit.
TECHNICAL SPECIFICATIONS
Capacity 40 Litres
Weight 8.35 kg
Exterior Dimensions (approx.)
Length : 57.1 cm
Height : 43.2 cm
Width : 37.8 cm
Voltage : 12 Volts DC / 240 Volts AC / 50 Hz built-in adaptor
Current : DC 3.5A /AC ~ 0.4A
Power Consumption : DC : 42 Watts ; AC : 55 Watts
Refrigeration system : Thermo electric solid state heat pump
Insulation Material : High quality full foam insulation of polyurethane, CFC-free
Case : polypropylene
Power cord 12V : 2.7 metre (approx.)
Power cord 240V : 1.5 metre (approx.)
Battery consumption : fully charge the battery by running the engine prior to using the unit for any
extended period when stationary.
If the battery runs down in this time you may have a faulty battery or alternator.
The unit can be used continuously while the vehicle is running, since the alternator provides more than
enough power.