The document outlines the tasks and responsibilities for cleaning in place (CIP) unit preparation, during CIP, and after CIP. It includes checking chemical concentrations and temperatures, ensuring equipment is properly cleaned, covered, and aligned, monitoring operating parameters, verifying for leaks, sampling, and recording data. Responsibilities are assigned to various staff including the chemist, plant operator, and electrician at different stages of the CIP process.
The document outlines the tasks and responsibilities for cleaning in place (CIP) unit preparation, during CIP, and after CIP. It includes checking chemical concentrations and temperatures, ensuring equipment is properly cleaned, covered, and aligned, monitoring operating parameters, verifying for leaks, sampling, and recording data. Responsibilities are assigned to various staff including the chemist, plant operator, and electrician at different stages of the CIP process.
The document outlines the tasks and responsibilities for cleaning in place (CIP) unit preparation, during CIP, and after CIP. It includes checking chemical concentrations and temperatures, ensuring equipment is properly cleaned, covered, and aligned, monitoring operating parameters, verifying for leaks, sampling, and recording data. Responsibilities are assigned to various staff including the chemist, plant operator, and electrician at different stages of the CIP process.
The document outlines the tasks and responsibilities for cleaning in place (CIP) unit preparation, during CIP, and after CIP. It includes checking chemical concentrations and temperatures, ensuring equipment is properly cleaned, covered, and aligned, monitoring operating parameters, verifying for leaks, sampling, and recording data. Responsibilities are assigned to various staff including the chemist, plant operator, and electrician at different stages of the CIP process.
No. Task Responsibility Status 1 Check Chemical Concentration (22 mS/cm) Chemist PO Check Not Check 2 Check Chemical Temperature (85 C) Chemist PO Check Not Check 3 Check CIP Strainer & Clean Chemist PO Check Not Check 4 Check CIP Swing Bend in syrup room (Must be alligned as per Loop requirement) Chemist PO Check Not Check 5 Check CIP return pump switch in CIP room according to Line wise. Electrician Chemist Check Not Check 6 Check the Ammonia valve is closed? PO Operator Check Not Check CIP unit preparation (In Filler Hall) No. Task Responsibility Status 1 Does the filler Cup propely cleaned & attached with valves PO Chemist Check Not Check 2 Does the CIP Bends are connected properly according to Loop Requirement. Chemist PO Check Not Check 3 Does All the CIP Loop valves are open (Filler Return, Flow mix & CIP) Chemist PO Check Not Check 4 Does all the Electrical Equipments (EBI, Sensor, Motors) are properly covered? PO Electercian Check Not Check 5 Does all the seals, Joints & valves has been checked? PO Chemist Check Not Check 6 Does all the finished product is removed from the plant? PO Chemist Check Not Check During CIP No. Task Responsibility Status 1 Monitoring of CIP operating parameters (Temperature, Flow rate, Conductivity & Contact Time) Chemist PO Check Not Check 2 Verification of any leakages in CIP loop (From filler valve, Joints, seal, valves, FM) Chemist PO Check Not Check 3 Check all the Electrical Equipments (EBI, Sensor, Motors) are protected from heat and water. Electrician PO Check Not Check 4 Verify the Flow-Mix, Syrup side, water side sampling valves are open. Chemist PO Check Not Check 5 Remove Air from return pump to avoid choking/Cavitation. PO Operator Check Not Check 6 Record all the operating parameters in log sheets. Chemist PO Check Not Check After CIP No. Task Responsibility Status 1 Preparation of COP chemical prior to CIP end. PO Chemist Check Not Check 2 Proper cleaning of all equipments (Carbo-Cooler, FM, Filller & Rest of units in filling Hall) PO Chemist Check Not Check 3 Verification of Cleaning results, Filler, FM, Carbo-cooler inspection Chemist PO Check Not Check 4 Micro sampling Chemist PO Check Not Check 5 Syrup attachment. Chemist po Check Not Check