Professional Documents
Culture Documents
Accent P0036 HO2S Heater Control Circuit Incorrect
Accent P0036 HO2S Heater Control Circuit Incorrect
1. Check resistance.
(1) IG "OFF".
(2) Disconnect HO2S(S2) connector.
(3) Measure resistance between terminal 3 and 4 of HO2S(S2) (Component Side)
Specification :
ITEM Specification
Heater Resistance(Ω) Approx. 9.0Ω at 20°C (68°F)
Substitute with a known - good ECM/PCM and check for proper operation.
If the problem is corrected, replace ECM/PCM and go to "Verification of Vehicle Repair" procedure.
Substitute with a known - good HO2S(S2) and check for proper operation.
If the problem is corrected, replace HO2S(S2) and go to "Verification of Vehicle Repair" procedure.
Fuel System > Troubleshooting > P0037 HO2S Heater Control Circuit Low (Bank 1 / Sensor 2)
COMPONENT LOCATION
Page 97 of 753
GENERAL DESCRIPTION
In order to control emissions of the CO, HC and NOx components of the exhaust gas, heated oxygen sensor
(HO2S), mounted on the front side and rear side of catalytic converter, detects the oxygen content in the exhaust
gas. The front HO2S signal is used to control air/fuel ratio (closed loop fuel control) and the rear HO2S signal is
used to monitor front HO2S and catalyst for proper operation.
The HO2S requires a minimum temperature to operate properly and provide a closed loop fuel control system. The
HO2S contains the heater element to reduce its warming-up time and ensure its performance during all driving
conditions.The ECM/PCM controls this heater element by duty cycle. The main relay supplies voltage to the heater
and the ECM/PCM provides a ground circuit for activating the heater.
DTC DESCRIPTION
When ECM/PCM detects short to ground in the heater control circuit(B1S2), ECM/PCM sets DTC P0037.
SPECIFICATION
ITEM Specification
Approx. 9.0Ω at 20°C
Heater Resistance(Ω)
(68°F)
SCHEMATIC DIAGRAM
(A/T)
Page 99 of 753
(M/T)
Page 100 of 753
Fault is intermittent caused by poor contact in the sensor’s and/or ECM’s connector or was repaired and
ECM/PCM memory was not cleared. Thoroughly check connectors for looseness, poor connection, ending,
corrosion, contamination, deterioration, or damage. Repair or replace as necessary and go to "Verification of
Vehicle Repair" procedure.
Specification : B+
COMPONENT INSPECTION
Page 102 of 753
1. Check resistance (S2).
(1) IG "OFF".
(2) Disconnect HO2S(S2) connector.
(3) Measure resistance between terminal 3 and 4 of HO2S(S2) (Component Side)
Specification :
ITEM Specification
Heater Resistance(Ω) Approx. 9.0Ω at 20°C (68°F)
Substitute with a known - good ECM/PCM and check for proper operation.
If the problem is corrected, replace ECM/PCM and go to "Verification of Vehicle Repair" procedure.
Substitute with a known - good HO2S(S2) and check for proper operation.
If the problem is corrected, replace HO2S(S2) and go to "Verification of Vehicle Repair" procedure.
Fuel System > Troubleshooting > P0038 HO2S Heater Control Circuit High (Bank 1 / Sensor 2)
COMPONENT LOCATION