Professional Documents
Culture Documents
Ambulance and Emergency Equipment - Catalogue - en PDF
Ambulance and Emergency Equipment - Catalogue - en PDF
Emergency Equipment
0$18)$&785(56
6Ζ1&(
)5207+(Ζ'($
727+(3$7Ζ(17
Contents 3
Contents
Suction
n V7 Portable Suction Units 14-15
n VacUp® Foot Pedal Suction Unit 16
n Manual Suction Pump 16
n Vacujet® “Venturi” Vacuum Device 17
Ventilation
n VITAE 40 Emergency and Transport Lung Ventilator 18-19
n Revivator® Plus and Revivator® Res-Q Manual Resuscitators 20-21
Emergency
n Oxivac® Rescue Backpacks, Bags and Drop Leg Utility Waist Pouches 22-23
n Oxivac® I and II Suitcases 23
n TIE® Tourniquet in Emergency 24
n R-2100 Intubation Set 25
n HED Body Splint with Lifting Bridle 25
n Laryngoscopes 26-27
4 Oxygen for ambulances
O2 CYLINDERS
P40DIS-NFS
ref. 5501011 TEE connector, Ø8 mm hose
ref. 3560033
7L Y connector, Ø8 mm hose
P40-NFS-ambulances ref. 3900145
ref. 5501411
Tube, 8 x 5.50 mm
ref. 3100120
P40-InGas-NFS
ref. 5501511 6.3 x 12 mm hose
2L ref. 0940001
6.3 x 12 mm hose
Female O2 DISS, 9/16”
F15-NFS
ref. 5503211 ref. 5900013
www.hersill.com
Oxygen for ambulances 5
Flow meters
PANEL EXTERNAL
Oxyll®
Exchanger + Manometer
ref. 5900580
Vacujet® "Venturi"
Exchanger: Control knob vacuum device
+ Manometer + 2 Valves
ref. 590024x
3 valves
ref. 590053x
ref. 4300002
2 valves
ref. 590052x Square bar 3 Valves Emergency
+ Manometer and transport
ref. 590074x VITAE 40 lung ventilator
ref. 5200800
1 valve
ref. 590051x
C3
C2
C1
OSR-ER-C3-V3-DIN
540 x 105 mm
ref. 5900267
Supply side
V1
Only valves V2
R = Right side
V3
E = EXTERNAL L = Left side
C2 + V2
B = Back side
Control + Valves C2 + V3
NF
C3 + V3
BS
V2
Only valves DIN
B = BAR R = Right side V3
AS
(square) L = Left side
Control + Valves C1+V2 DISS
V1 UNI
Only valves V2
V3
P = PANEL
Control + Valves C1+V2
C2
Only control
C3
www.hersill.com
Oxygen for ambulances 7
V = Valves
EXAMPLES
OSR-P-C1-V2DIN 180 x 80 mm
ref. 5900547
InGAS®
O2 Cylinder Intelligent Changeover
System
Intelligent system controlled by a microprocessor
for the management and changeover of two high pressure
cylinders.
Dimensions: 23 x 18 cm
ref. 552050x
n InGAS control module. n S mart selection of cylinder in use. The lowest pressure
cylinder is selected, keeping a higher back-up.
n P-300 Pressure regulators with sensor. n Constant delivery of oxygen delivery guaranteed.
n Self-test.
n Panel mount back-up O2 valve.
Ordering
5520500 5520501 5520502 5520503 5520504 5520505 5520506
information
www.hersill.com
Oxygen for ambulances 9
Oxygen Cylinders
Empty
Material Steel
Valve types NF
Any other size or valve available upon request: DIN, NF, BS, CGA 540, PIN INDEX, etc. [Please consult].
10 Oxygen for ambulances
Oxyll® Oxyll®
Ball Flow Meters
n ompensate the variations of pressure of the pipeline: admit all the pressure
C Oxyll®
of the line, maintain it and provide the selected flow under atmospheric pressure selector
to the patient, through either a mask, a nasal catheter, an humidifier, etc.
n Scale design: good visibility of the flow selection from an angle of up to 180º.
n Brass (matt chrome-plated) body and DISS outlet, polyamide regulation control
knob, polycarbonate inner and outer tubes and stainless-steel float. Latex-free.
nO xyll® selector: time and O2 saving. Via a revolving control knob, O2 is supplied
continuously through a direct outlet to either a face mask, a nebulizer or a
humidifier.
Without fitting
L/min Whitworth G1/8" H SS8752430 BS 5682 NF 90 116 Oxifar B DIN 13260
O2
0-15 4540000 5540000 5540002 5540003 5540005 5540006
Air
0-15 4540300 5540300 5540302 5540303 5540305 5540306
Special fittings are available upon request. [Please contact HERSILL for details].
www.hersill.com
Oxygen for ambulances 11
Perflow® Perflow® P4
Perflow®
multy
Perflow® P5
Click Style Dial Flow Meters
n igh-precision calibrated orifices and a controller knob with click style
H
positioning.
n High-visibility and large-diameter display showing the selected flow,
Perflow® Perflow® P4/P5 Perflow® P4/P5 selector Perflow® multy Perflow® multy selector
Dimensions 37 x 56 mm 38 x 79 mm 38 x 65 mm 38 x 88 mm
Weight 98 g 190 g 112 g 200 g
Outlet fitting DISS 02 9/16”-18 UNF
Fixed Variable
Inlet pressure
4 bar 50 psi 2.8 – 7 bar 40 – 100 psi
Without
fitting
Whitworth
L/min SS8752430 BS 5682 NF 90 116 Oxifar B DIN 13260 DISS
G1/8" H
O2
P4 OX15 4540800 5540801 5540803 5540804 5540806 5540807 5540810
P4 selector OX15 4540700 5540701 5540702 5540703 5540706 5540707 5540709
P4 OX50 4540810 5540811 5540813 5540814 5540816 5540817 5540819
P5 OX15 4540880 5540889
P5 selector OX15 4540780 5540789
P5 OX50 4540885 5540889
multy OX1 4540840 5540841 5540843 5540844 5540846 5540847 5540849
multy OX5 4540850 5540851 5540853 5540854 5540856 5540857 5540859
multy selector OX5 4540750 5540751 5540753 5540754 5540756 5540757 5540759
multy OX15 4540860 5540861 5540863 5540864 5540866 5540867 5540868
multy selector OX15 4540760 5540761 5540763 5540764 5540766 5540767 5540769
Air
P4 AIR15 4540820 5540821 5540823 5540824 5540826 5540827 5540829
P4 AIR50 4540830 5540831 5540833 5540834 5540836 5540837 5540839
P5 AIR15 4540890 5540898
P5 AIR50 4540895 5540899
multy AIR15 4540870 5540871 5540873 5540874 5540876 5540877 5540879
Special fittings are available upon request: Chemetron, Ohmeda, Puritan, UNI, AFROX, ENV 737-6 [See page 10]
12 Oxygen for ambulances
P-300
Brass O2 pressure regulators
Oxygen Pressure Regulators
Fixed Flow Adjustable Flow Designed to be used up to 300 bar,
optimizing the O2 consumption.
Guaranteeing a high-stability of the outlet
pressure and precise flows.
Safe and accurate over-pressure valve.
(1) 0 0.1 0.15 0.2 0.25 0.3 0.35 0.4 0.5 0.6 0.7 0.8 0.9 1 (3) 0 0.2 0.5 0.7 1 1.5 2 3 4 5 7 10 12 15 -50
(2) 0 0.1 0.2 0.3 0.4 0.6 0.8 1 1.5 2 2.5 3 4 5 (4) 0 0.5 1 2 3 4 5 6 8 10 15 20 25 30
www.hersill.com
Oxygen for ambulances 13
H-350
Compact oxygen therapy equipment containing:
ref. 5506012 n Oxygen regulator with manometer 0-400 bar and NFL cylinder fitting
with O.15 L/min ball flow meter.
n Plastic connector DISS (9/16"-18 UNF) to nipple for O2 tubing.
3 5
1
V7 V7 plus b
Portable Suction Units emergency
V7 plus b
V7 suction units are compatible with the main brands of disposable suction systems worldwide. [Please consult availability].
www.hersill.com
Suction 15
V7 plus b
V7 ac V7 dc V7 plus ac V7 plus dc V7 plus b V7 mx V7 g
emergency
5320201 5320211 5320241 5320251 5320261 5320281 5320236 5320271
With PC1 suction jar
5321201 5321241
5320202 5320212 5320242 5320252 5320262 5320282 5320237 5320273
With PC2 suction jar
5321200 5321240
100/240 Vac 100/240 Vac
220 Vac 50Hz 12 Vdc 220 Vac 50Hz 12 Vdc 12 Vdc 12 Vdc
Power supply 12 Vdc 12 Vdc
110 Vac 60Hz 110 Vac 60Hz Battery Battery
Battery Battery
5 L/min
Free air suction flow 20 L/min 14 L/min 30 L/min 30 L/min 30 L/min 30 L/min 30 L/min Continuous/
Intermittent
80 kPa 75 kPa 84 kPa 84 kPa 84 kPa 84 kPa 84 kPa 20 kPa
Maximum vacuum
600 mmHg 562 mmHg 630 mmHg 630 mmHg 630 mmHg 630 mmHg 630 mmHg 150 mmHg
160 W (ac) 35 W (ac)
Electric power 250 W 18 W 120 W 85 W 85 W 85 W
84 W (dc) 30 W (dc)
12 V-4.5 Ah 12 V-4.5 Ah 12 V-4.5 Ah 12 V-1.3 Ah
Internal battery Ac-Pb Ac-Pb Ac-Pb Ac-Pb
65 min 65 min 65 min 120 min
Bacteria filter ✓ ✓ ✓ ✓ ✓ ✓ ✓ ✓
VacUp®
Foot Pedal Suction Unit
n Intensive vacuum since the very first compression
(– 0.82 bar, -61 cmHg, -82 kPa). Sweep-vacuum-gauge.
Manually vacuum relief valve. High-volume output
(28 L/min at 2 compressions per second. 72 L/min maximum). Tank
useful capacity: 650 ml (includes overfilling valve).
n Dimensions: 180 x 130 x 110 mm (folded).
ref. 0300015
www.hersill.com
Suction 17
Vacujet®
"Venturi" Vacuum Device
Designed to provide an
adjustable high-vacuum in
the event of only compressed
air or oxygen available.
Includes an ON/OFF switch
and vacuum-regulation knob.
Low noise level. Exhaust gas
system integrated.
Vacujet®
with Vacujet®
SafetyTrap with
water trap PC hydrophobic
and without bacteria
fitting filter
ref. 5300000 ref. 5300100
Accessories
8 x 13 mm ref. 0940023
9 x 15 mm ref. 0940029
6 x 8 mm ref. 0310018
(80 cm)
18 Ventilation
VITAE 40
Emergency and Transport Lung Ventilator
Monitoring:
n Ventilation curves: P/t, F/t, V/t, CO2/t (2), V/F, P/V, F/P, ExCO2/V (3).
nVentilation trends: P ip; VM e, VT e, EtCO2 (2).
entilation parameters: P ip, VT e, F, F spont., VM e, VT i, InCO2,
nV
www.hersill.com
Ventilation 19
Ventilation settings:
nT idal volume (VT): 5 to 3000 mL n F iO2: 40 to 100 % O2
(from 20mL for volume (increments 10 %)
modes) n Inspiratory pressure: 5 to 60 mbar
nV entilation frequency: 3 to 80 /min nInspiratory time (T Insp): 0.4 to 5.0 s
nI:E relation: 2:1 to 1:8 nR amp: 0.2 to 2.1 s
nP EEP: 0 to 25 mbar n P ressure support (PS): 5 to 60 mbar
nT rigger: 1 to 1 L/min
nP max: 5 to 60 mbar Inspiratory flow: max. 120 L/min
Revivator® Plus
n Face mask and patient valve with a full 360º rotation to allow an easy and handy ventilation from every position.
n Includes an outlet to allow you to attach a pressure gauge of 0-60 cmH2O to control the airway pressure.
n S et includes: rigid transport case in polypropylene, resuscitator with silicone mask, O2 extension tube,
O2 reservoir and 2 Guedell tubes.
www.hersill.com
Ventilation 21
Revivator® Res-Q
n Face mask and patient valve with a full 360º rotation, allowing an easier and
Without O2 Reservoir
Adult ref. 5200702
Child ref. 5200712
With O2 Reservoir
Adult ref. 5200701
Child ref. 5200711
#5 #4 #3 #2 #1 #0
0200045 0200044 0200043 0200042 0200041 0200040 #6 #5 #4
3200006 3200005 3200004
+ +
Polysulfone mask covers
#3 #2 #1
#4 and 5 #3
0200049 0200048 3200003 3200002 3200001
22 Emergency
Oxivac® Rescue
Backpacks, Bags and Drop Leg Utility Waist Pouches
Emergency equipment including the essential elements for cardiopulmonary resuscitation: oxygen, suction and ventilation.
Shell: Lining:
n M
ade of material which prevents fabric edge n Blue or grey coloured- PVC coated polyester.
unstitching and fraying. n Inside perimeter containing elastic bands alongside.
n Black PVC matte antiestatic canvas bottom n Velcro: bands across surface to attach accessories,
reinforced corners and/or end floor protectors. webbing straps and adjustable hook and loop/
n Polypropylene gripping and adjustable straps. buckle straps.
Oxivac® Kits
Oxigen Therapy
Ref.: 3210221 Adult oxygen mask
Ref.: 3210220 Child oxygen mask
Reanimation
Ref.: 5200701 Silicone resuscitator Revivator® Res-Q adults with O2 reservoir, 2.5 L and 2 face masks (adult and child)
Ref.: 3210007 Thermal blanket
Ref.: 3210008 Mouth opener
Ref.: 3210006 Bandage scissors
Ref.: 3210009 Tongue forceps
Airway
Ref.: 0200007 Set of 3 Guedell cannulas # 1, 3 and 5
Ref.: 0131478 Endotracheal stylet and 2 units of single use-endotracheal tubes with balloon (adults and children)
Suction
Ref.: 5300200 VacUp® pro unit. Useful capacity of tank: 650 ml
Ref.: 0310026 Suction catheter # 16
Ref.: 0310005 Yankauer suction cannula
Optional
400 L empty oxygen cylinder, Ø110 mm, 321 mm (H). Different cylinder fittings available, please consult
ref. 0200055 2 L
22 x 47.20 cm
WxH
ref. 0200039 5 L
35.5 x 50 cm
n 3
ID holders and 5 exterior pockets: 2 at the top, 1 on the backside to insert WxH
a trolley and hide shoulder strap, 1 across the cover (includes a net pocket)
and 2 side pockets. Microprismatic reflective tape, visible from any angle (GP340 tape: ISO 20471:2013).
n 4 interior removable velcro zipper pouches + 2 optional extra ones (international colour-coding system).
www.hersill.com
Emergency 23
ref. 0200038
6.5 x 16 x 17 cm
WxLxH
n 1
exterior velcro bellows pocket.
n 1
interior pocket.
Oxivac® I and II
Suitcases
High-density polyethylene double-bottom suitcase, very resistant to impacts, 100% recyclable, including:
n P
-300 pressure regulator.
n R
evivator® Res-Q silicone resuscitator for adults equipped with O2 reservoir and 2 face masks (adult and child).
n S
et of 2 O2 face masks (adult and child), blanket, scissors, tongue forceps and mouth opener.
n S
et of 3 Guedell cannulas # 1, 3 and 5.
n 3
quick-access zipper pouches with clear-view vinyl lid.
n O
2 cylinder not included. Optional: 02 cylinder, 400 L.
n D
imensions (W x L x H): 16.5 x 47.5 x 36 cm.
Oxivac® I Oxivac® II
ref. 5210301 ref. 5210302
Without O2 cylinder Without O2 cylinder
P-300-FX5-NFS P-300-F15-NFS
24 Emergency
TIE®
Tourniquet in Emergency
n Adjustment of windlass rod every 90º.
n Compression plate of 7.4 cm length for use by children and adults.
Time identifier:
n Resistant windlass fixing clip and blocking tab for windlass rod.
starting time of
n Rigid and unbreakable windlass rod. Made of non-slip grooved
ischemia
material for a better grip and adjustment every 90º.
Easy application:
insertion direction of
strap through buckle
Double Safety 1 2
ref. 0200130 BLACK (NSN 6515332153184) ref. 0200131 NATO GREEN (NSN 6515332077128)
Tourniquet pouch
n Tourniquet pouch including a hook-n-loop adjustable front closure
with red tip indicating opening direction and a single rear MOLLE
strap to easily attach onto belts, bags and chest rigs.
ref. 0200132
www.hersill.com
Emergency 25
R-2100
Intubation Set
Nylon carry zipper pouch, including:
n Laryngoscope
with handle and two
ref. 5220100
Macintosh spatulas (# 2 and 4).
n P
laster cloth, adult Magill forceps,
Pean tweezers, syringe (10 ml), bandage
scissors, and exploration flashlight.
n E
ndotracheal tubes with balloon
# 5, 6, 7, 8, 9 and 10, in addition
to two stylets for endotracheal tubes.
Dimensions (W x L x H): 8 x 34.5 x 26.2 cm
n
n Weight: 1.30 Kg
HED
Body Splint with Lifting Bridle
n A
ttachable 3-point lifting sling equipped
with 3 high-security locking carabiners.
n Adjustable body splint with non-slip straps
and 5 high security locks.
n Forehead and chin padded slings.
n H ead-rest pillow.
n Transport cover.
n D
imensions (W x H): 81 cm x 83 cm
n W eight: 3.5 Kg
ref. 0200023
26 Emergency
Laryngoscopes
Stainless steel blades, AISI-304, non-magnetic,
with integrated and removable fiber optic.
Reusable and autoclave sterilizable.
Megaray
Blades with Fiber Optic Internal light conductor
n S
tainless steel blades Macintosh # 0, 1, 2, 3, 4 and 5. 2.5 V Xenon bulb.
n
n M
iller Stainless steel blades # 00, 0, 1, 2, 3 and 4. n R
igid plastic case.
Flexiray
Articulated blade for better flexibility and control in difficult circumstances
n M acintosh, stainless steel blades # 2, 3 and 4.
n Rigid case suitable for 1 handle and 2 blades.
www.hersill.com
Emergency 27
n hrome-plated plated brass hook-on handles, Green System German, with 2.5 V LED light
C
(pure white), compatible with any laryngoscope blade.
Ref.: 0130150 Hook on handle Type-C, Standard (Ø29 mm x 160 mm)
Ref.: 0130131 Hook on handle Type-AA, Penlight (Ø19 mm x 160 mm)
Ref.: 0130132 Hook on handle - Short, Stubby (Ø34 mm x 118 mm)
Ref.: 0130159 2.5 V LED handle lamp (spare part)
n hrome-plated brass hook-on handles, Green System German, with 2.5 V Xenon light,
C
compatible with any laryngoscope blade.
Ref.: 0130117 Hook on handle Type-C, Standard (Ø29 mm x 160 mm)
Ref.: 0130126 Hook on handle Type-AA, Penlight (Ø19 mm x 160 mm)
Ref.: 0130127 Hook on handle - Short, Stubby (Ø34 mm x 118 mm)
Ref.: 0130147 2.5 V Xenon lamp holder
Ref.: 0130116 2.5 V Xenon bulb (spare part)