Professional Documents
Culture Documents
Temperature Control With A PID Controller
Temperature Control With A PID Controller
ENGINEERING
Members:
Allag, Austin Kyle
Mendoza, Bernard Benedict
Santiago, Jerome
Villasencio, Julienne Marie
detected, and the passage of heat energy into or out of the space or substance is
The Temperature control system with a PID controller is used to monitor and
value for constant and the three values needed for the PID controller is tuned.
Values for the temperature of hot and cold water, flow rate and volume is also
user defined.The behavior of the system is observed by using two scopes, one for
The final GUI has five textboxes for the values of set point of temperature,
temperature of hot water, temperature of cold water, flow rate and the volume.
One push button for plotting the error and the final temperature.
Proposed Block Diagram
The block diagram has a initial setpoint value. It goes to the tuned PID Controller
which has fixed values for Kp, Ki, and Kd. After that it goes to the process block.
The process block accepts 4 parameters namely: temperature of hot water,
temperature of cold water, flow rate and the volume for the final computation. A
scope is connected before the PID controller for error measurement, and a scope
for the output to observed the final temperature.
Block diagram inside the Process Block