Equipment to be Installed Recommended Installation Steps
• ONYX® FIRSTVISION Performing the following steps will accomplish mounting • AMPS-24/E Power Supply the ONYX® FIRSTVISION and the power supply components, and also the wiring connection between • BB-100 Cabinet for the AMPS-24/E them. • Two 100 Amp-Hour Batteries Step 1. Mounted the panel on an inside wall of a building. Building construction and local building Installation Standards and Codes codes dictate installation parameters. Panel The ONYX® FIRSTVISION has been designed to comply dimension are shown on the reserve side of this with standards set forth by the following regulatory document in Figure 1.1. agencies: Step 2. Mount the AMPS 24/E and the batteries in a BB- • Underwriters Laboratories Standard UL 864 100 Mounting as described in the AMPS-24/E Manual. • NFPA 72 National Fire Alarm Code • CAN/ULC - S527-99 Standard for Control Units for NOTE:It is recommend that power be turned-on to the AMPS Fire Alarm Systems 24/E and ONYX® Insight after the Ethernet (TCP/IP) Network • ULC S524 Standard for the Installation of Fire Alarm and the NFN Gateway connections have been made. Systems The contents of this document are important and must be Step 3. Open and locate the terminal power strip inside kept in close proximity to the hardware. If building the ONYX® FIRSTVISION cabinet as shown on ownership is changed, this document and all other the reserve side of this document in Figure 1.2. testing and maintenance information must also be Step 4. Wire the AMPS 24/E to the terminal strip on the passed to the current owner of the facility. A copy of this ONYX® FIRSTVISION cabinet as shown on below. document is shipped with the ONYX® FIRSTVISION and is also available from the manufacturer. TB6 provides 1 amp, power-limited, when the +5V output is not being used. Do not use the +5V output at the same time. WARNING:Improper installation, maintenance, or lack of routine testing could result in system malfunction.
UL 9th Edition Compliance
This product has been certified to comply with the requirements in the Standard for Control Units and AMPS 24/E Accessories for Fire Alarm Systems, UL 864 9th Edition. Operation of this product with products not tested for UL ONYX® FIRSTVISION 864 9th Edition has not been evaluated. Such operation requires the approval of the local Authority Having Cabinet Jurisdiction (AHJ).
NOTE:The AMPS-24/E Power Supply has not received
UL 864 9th Edition certification. Step 5. Refer to ONYX® FIRSTVISION Operating and Programming Manual (52442) for information about connecting the ONYX® FIRSTVISION with building systems. Environmental Conditions The ONYX® FIRSTVISION must be installed in the following environmental conditions: • Temperature range of 0ºC - 50ºC (32ºF - 120ºF). • 10-95% humidity non-condensing at 30ºC (86ºF). • Vibration of 10-50Hz, 0.5G Peak to Peak • Shock 15G, 11ms maximum
Document 52441 Rev A ECN 04-559 06/06/2005
Figure 1.1 ONYX® FIRSTVISION Dimensions
Figure 1.2 Location of ONYX® FIRSTVISION Terminal Strip
The ONYX® Insight panel is
already internally wired from the power port to a terminal back of display strip.