Professional Documents
Culture Documents
Manual Danfoss 101N0212
Manual Danfoss 101N0212
Manual Danfoss 101N0212
The electronic unit is a dual voltage device. This Thermostat and speed selection In case the electronic unit records an operational
means that the same unit can be used in both Either an NTC (electrical thermostat, 11) or a error, the diode will flash a number of times. The
12V and 24V power supply systems. Maximum mechanical thermostat (10) can be connected number of flashes depends on what kind of
voltage is 17V for a 12V system and 31.5V for between the terminals C and T. operational error was recorded. Each flash will
a 24V power supply system. Max. ambient If an NTC is used, the set point and speed can last ¼ second. After the actual number of flashes
temperature is 55°C. The electronic unit has a be set via a communication interface between there will be a delay with no flashes, so that the
built-in thermal protection which is actuated terminals C and D/I. sequence for each error recording is repeated
and stops compressor operation if the electronic If a mechanical thermostat is used without any every 4 seconds.
unit temperature gets too high. R1 resistor (8), the compressor will run with a
fixed speed of 2,000 rpm. Other fixed compressor
Installation (Fig.1) speeds in the range between 2,000 and 3,500
Connect the terminal plug from the electronic rpm can be obtained when a resistor (8) is Operational errors
unit to the compressor terminal. Mount the installed to adjust the current (mA) of the control
electronic unit on the compressor by snapping circuit. Resistor values for various motor speeds
the cover over the screw head (1). appear from Fig. 5.
Danfoss can accept no responsibility for possible errors in catalogues, brochures and other printed material. Danfoss reserves the right to alter its products without notice. This also applies to products
already on order provided that such alterations can be made without subsequential changes being necessary in specifications already agreed.
All trademarks in this material are property of the respective companies. Danfoss and the Danfoss logotype are trademarks of Danfoss A/S. All rights reserved.
FRCC.PI.034.A1.02 - January 2015 - Replaces DEHC.EI.100.B6.02 Manufactured by Secop for Danfoss © Copyright Danfoss | Commercial Compressors | 2015.01