Professional Documents
Culture Documents
Kamala Niketan Montessori School (Cbse) Trichy: Self Designed Transformer
Kamala Niketan Montessori School (Cbse) Trichy: Self Designed Transformer
Kamala Niketan Montessori School (Cbse) Trichy: Self Designed Transformer
SUBMITTED BY,
M.RASENA
NILOFER
X11-J
INDEX:
1. INTRODUCTION
2. AIM
3. APPARATUS REQUIRED
4. THEORY
5. PROCEDURE
6. OBSERVATION
7. RESULT
8. PRECAUTIONS
9. BIBLIOGRAPHY
INTRODUCTION:
AIM:
APPARRATUS REQUIRED:
1. AN IORN ROD
Let Np and Ns are the no. of turns of the primary and secondary coils
of the transformer respectively.
Es / Ep = Ns / Np =K --------(3)
Ip = E – Ep / Rp
E – Ep = Ip Rp
E – Ep = 0 or Ep = E
Es / Ep = Es / E
= Ns / Np = K
In a step up transformer
And,
Therefore,
And,
Then,
Ep Ip = Es Is
Es / Ep = Ip / Is = Ns / Np = K
In a step up transformer
Efficiency:-
= Es Is / Ep Ip
Energy losses:-
I. Flux Leakage:-
There is always some flux leakage; that is, not all of the flux due
to primary passes through the secondary due to poor designs of
core or the air gaps in the core. It can be reduced by winding the
primary and secondary coils one over the other.
The wire used for windings has some resistance or so, energy is
lost due to heat produced in the wire (I 2R). In high current, low
voltage windings, these are minimized by using thick wires.
IV. Hysteresis:-
CONSTRUCTION:-
CIRCUIT DIAGRAM:-
PROCEDURE:
1. Take a thick iron rod and cover it with a thick paper and wind a
large number of turns of thin Cu wire on thick paper. This
constitutes primary coil of the transformer.
2. Cover the primary coil with a sheet of paper and wound
relatively smaller number of turns of thick copper wire on it.
This constitutes the secondary coil. It is a step down
transformer.
3. Connect P1P2 to A.C. mains and measure the input voltage and
current, using A.C. voltmeter and ammeter respectively.
4. Similarly, measure the output voltage and current through S1S2.
5. Now connect the S1S2 to A.C. mains and again measure voltage
and current through primary and secondary coil of step-up
transformer.
6. Repeat all steps for other self made transformer by changing
number of primary turns in secondary coils.
OBSERVATION: