Professional Documents
Culture Documents
WBBP PDF
WBBP PDF
NOTE:
There is no label indicating the board type on the lower left corner of a WBBPa.
On a WBBPb1, a WBBPb2, a WBBPb3, and a WBBPb4, there are silkscreens WBBPb1, WBBPb2,
WBBPb3, and WBBPb4, respectively. Figure 2 shows a WBBPb1 panel.
On a WBBPd1, a WBBPd2, and a WBBPd3, there are silkscreens WBBPd1, WBBPd2, and
WBBPd3, respectively. Figure 3 shows a WBBPd1 panel.
On a WBBPf1, a WBBPf2, a WBBPf3, and a WBBPf4, there are silkscreens WBBPf1, WBBPf2,
WBBPf3, and WBBPf4, respectively. Figure 4 shows a WBBPf1 panel.
Specifications
NOTE:
NOTE:
The baseband processing board in slot 2 or 3 in a BBU3900 can transfer received CPRI data to
other boards.
b: The number of HSDPA codes supported by a WBBPd1 is 6x15, in which 6 is the number of
cells and 15 is the number of HSDPA codes supported by each cell.
NOTE:
For combined signaling specifications of a board, see section "Technical Specifications of the BBU3900s
and BBU3910s" in 3900 Series Base Station Technical Description.
Function
Working Principle
The following figure shows the working principle of a WBBP.
Port
The following table describes the six CPRI ports on WBBPa and WBBPb panels.
Table 2 Ports on WBBPa and WBBPb panels
Table 6 Mapping between CPRI data rate and number of cells supported
CPRI Port Rate (Gbit/s) Number of 1T2R Cells Number of 2T2R Cells
1.25 4 4*a
2.5 8 8*a
4.9 16 16*a
6.144 24 24*a
a: The asterisk (*) in the table indicates that the number of 2T2R cells is halved if the 2T2R
cells support the virtual antenna mapping (VAM) function and the two TX antennas used by
the VAM function are separately connected to two RF modules carried on different CPRI links.
NOTE:
In a GU dual-mode base station where the GTMU is connected to the WMPT or UMPT through ports on
their panels, part of CPRI bandwidth of the UMTS side is reserved for a TX and an RX channel of the GSM
side in case that bandwidth on the GSM side is insufficient. As a result, the cell number supported by the
UMTS side is reduced.