Professional Documents
Culture Documents
Technical Bulletin No. RTB-001: User-Code 0 (U-0)
Technical Bulletin No. RTB-001: User-Code 0 (U-0)
RTB-001
SUBJECT: Service Manual Correction DATE: April 30, ’95
PAGE: 1 of 1
PREPARED BY: S. Hizen FROM: 2nd Technical Support Section
CHECKED BY: M. Iwasa
CLASSIFICATION: MODEL:
Action Required Revision of service manual Robin
Troubleshooting Information only
Retrofit Information Other
User-Code 0 (U-0)
The User-code 0 (U-0) is missing in the code section of your service manual page 4-24.
Please add the User-code 0 in your service manual.
U-0:
The first scanner may accidentally move away from its home position during transportation
/ location change of the machine. If the main switch is turned on under this condition, U-0
appears.
Solution:
NOTE: U-0 is different from E21/E22. The scanner home position sensor has no problem
for U-0, while the sensor may be defective for E21/E22.
Technical Bulletin No. RTB-002
SUBJECT: Upper Unit Opening Problem DATE:May 15, ’95
PAGE: 1 of 5
PREPARED BY: S. Hizen FROM: 2nd Technical Support Section
CHECKED BY: M. Iwasa
CLASSIFICATION: MODEL:
Action Required Revision of service manual Robin (A151 / A152)
Troubleshooting Information only
Retrofit Information Other
- Problem -
When the upper unit without the document feeder is released, it tends to open very
abruptly.
- Cause -
To reduce the torsion force, parts of the front and rear angle brackets which support the
torsion spring have been cut off as shown:
To make it possible to adjust the force of the upper unit opening in the field, the
configurations of the front and rear angle brackets have been changed as shown.
Old New
P/N A1521198
P/N A0771098 (Torsion Bar Angle Bracket-Rear)
(Torsion Bar
P/N A0771197 Angle - Rear) P/N A1521197
(Torsion Bar (Torsion Bar Angle (S/Ns of Dec. production
Angle - Front) unit will be put in) - Front)
The Cut-in serial numbers for this modification are as follows:
Machine Code Cut-in Serial Number Machine Code Cut-in Serial Number
A151 - 10 2675030001 A152 - 10 2695020001
A151 - 15 1A25030001 A152 - 15 1A35020001
A151 - 16 2675030051 A152 - 16 ----
A151 - 17 A3605030154 A152 - 17 A3615030945
A151 - 22 2665020001 A152 - 22 2685030001
A151 - 24 ---- A152 - 24 ----
A151 - 25 2665020116 A152 - 25 2685030121
A151 - 26 3F20350001 A152 - 26 3F30350001
A151 - 27 A3605030001 A152 - 27 A3615030001
A151 - 28 ---- A152 - 28 ----
A151 - 29 A3605030754 A152 - 29 A3615032090
Front Rear
Strongest
C Strongest Setting
Setting C
Technical Bulletin No. RTB-002
SUBJECT: Upper Unit Opening Problem DATE: May 15, ’95
PAGE: 4 of 5
Front Rear
- Factory Setting -
C C B A
- Strongest Setting -
Remove the adjusting
bracket (2 screws on
B each side)
A
• Rotate the
bracket 180°
and install it
•Screw using holes A
and C. •Screw
A
B C
A
C B
- Factory Setting -
B A
C - Weak Setting -
• Remove the
adjusting
B bracket (2
A screws on each C
side).
•Screw • Rotate the
bracket 180° •Screw B C
A and install it
using holes B
and A.
A
C B
Technical Bulletin No. RTB-002
SUBJECT: Upper Unit Opening Problem DATE: May 15, ’95
PAGE: 5 of 5
For field machines, we have prepared the following plate as a countermeasure part to add
weight to the upper unit.
Please install two of the above plates on the machines as described in the following
procedure:
- Installation Procedure -
4. Peel off the seal from the plate [C] and stick the plate on the right development stay.
[A]
REVISED ON DECEMBER 15, ’95 : Revised
With this modification, to conserve energy, the copier automatically turns off 30 minutes
after the last copying job has been completed.
The details of the machine operation can be found on pages 3 to 4 of this RTB.
TO T402
Main Switch
DC Harness
Harness
Main Switch
REVISED ON DECEMBER 15, ’95 : Revised
Instruction Sheet
An additional explanation sheet has been added to the operating instructions booklet.
Please refer to pages 3 and 4 of this RTB for the contents of this sheet. The Energy
Saver Mode described on the second page of this instruction sheet is the Auto Energy
Saver Mode originally available with this copier.
REVISED ON DECEMBER 15, ’95 : Revised
*
REVISED ON DECEMBER 15, ’95 : Revised