Download as pdf or txt
Download as pdf or txt
You are on page 1of 7

 

Nokia AirScale Radio Description AirScale RRH 4T4R B66 160W (FRIJ)

8 AirScale RRH 4T4R B66 160W (FRIJ)


FRIJ technical specifications.
Functional description

Table 10 FRIJ functional specification
Property Value
Output power 4x40 W

MIMO 4TX
DRAFT VERSION

Outdoor installation Yes
SW supported technology FDD-LTE
TX frequency range 2110 - 2200 MHz
RX frequency range 1710 - 1780 MHz
DL instantaneous bandwidth 90 MHz
UL instantaneous bandwidth 70 MHz
DL filter bandwidth 90 MHz
UL filter bandwidth 70 MHz

Interfaces

Figure 4 FRIJ interfaces
OPT3 EAC OPT2 OPT1 RET DCIN GND

ANT4 ANT3 ANT2 ANT1

Table 11 FRIJ interfaces
Interface Label on the HW Number of Connector type Additional info
interfaces
Power Connector DC IN 1 3-pole screw
terminal

Issue: 01 DRAFT DN09236379 19
   

AirScale RRH 4T4R B66 160W (FRIJ) Nokia AirScale Radio Description

Table 11 FRIJ interfaces (Cont.)
Interface Label on the HW Number of Connector type Additional info
interfaces
Antenna ANT 4 4.3-10
connector
Remote Electrical RET 1 8-pin circular
Tilt
External Alarm EAC 1 USB 3.0 Type-A
Connection
Optical interface OPT 3 SFP+ 6 Gbps, OBSAI
DRAFT VERSION

Ground 1 M8 or dual M5
screws

Fan Fan 1 2 circuits Micro- Located on the


Fit side of the unit.

Antenna Line Devices (ALDs) support

Table 12 FRIJ ALD support
ALD support via antenna ports Value
AISG ANT1, ANT3, RET: AISG 2.0
Proprietary AISG1.1 No
CWA (for non-AISG installations) No
Voltage ANT1, ANT3: 14.5 V
RET: 14.5 V

Power per port 40 W
Power 60 W

Functional block diagram

20 DN09236379 Issue: 01 DRAFT
   

Nokia AirScale Radio Description AirScale RRH 4T4R B66 160W (FRIJ)

Figure 5 FRIJ functional block diagram

RRH Filter

TX
PA filter Bias-T VSWR
UniTX Tx/Rx
FPGA Det ANT 1
RX
LMP filter
LNA
TX
PA filter VSWR
Tx/Rx
OpticalIF UniRx Det ANT 2
RX
filter
LNA
DRAFT VERSION

OpticalIF RF PA TX
Bias-T VSWR
control filter
UniTX Tx/Rx
FPGA Det ANT 3
RX
filter
OpticalIF LNA
TX
PA filter VSWR
Tx/Rx
UniRx Det ANT 4
RX
filter
LNA

DCIN
PSU
BWextension

Electrical specifications

Table 13 FRIJ electrical specifications
Property Value
Nominal supply voltage -48.0 V DC
Nominal input voltage range -40.5 V DC to -57.0 V DC
Extended input voltage range -36.0 V DC to -40.5 V DC
-57.0 V DC to -60.0 V DC

Power consumption

Table 14 FRIJ power consumption
Mode Configuration Output power Estimated power consumption [W] at 48VDC
per carrier input at 25°C. Non-committed estimated
[W] values depend on the final product HW and
SW optimization with +/- 10% margin.
Average = (6h low hour load, 10h medium
hour load and 6h busy hour load) / 24h
Power Power Power
consumption consumption consumption
ETSI 202706 ETSI 202706 100% RF
average busy hour power load
PRRH, static load PBH RRH, P100% RRH
static

LTE 1/1/1 2T2R 20+20 634 709 868

Issue: 01 DRAFT DN09236379 21
   

AirScale RRH 4T4R B66 160W (FRIJ) Nokia AirScale Radio Description

Table 14 FRIJ power consumption (Cont.)
Mode Configuration Output power Estimated power consumption [W] at 48VDC
per carrier input at 25°C. Non-committed estimated
[W] values depend on the final product HW and
SW optimization with +/- 10% margin.
Average = (6h low hour load, 10h medium
hour load and 6h busy hour load) / 24h
Power Power Power
consumption consumption consumption
ETSI 202706 ETSI 202706 100% RF
average busy hour power load
PRRH, static load PBH RRH, P100% RRH
DRAFT VERSION

static

1/1/1 2T2R 40+40 746 886 1163


1/1/1 4T4R 4x20 1005 1155 1473
1/1/1 4T4R 4x40 1235 1512 2109

Installation and mechanical specifications

Table 15 FRIJ installation and mechanical specifications
Property Value
Installation options • wall installation
• pole installation
• flat mount on wall or pole
• face mount without fans
• vertical book mount without fans
• horizontal book mount with fans
• inside the Radio Antenna System (RAS)
with/without fans

IP rating IP65
Related optional items • Pole Mounting Kit 30-120 mm (AMPA)
• 4T4R AirScale REL4 Fan Assembly
• Flexi Power AC/DC Submodule 230V
(FPAE)
• EAC Cable USB3 Type-A (ATAA)
• Flat Mount Adapter Bracket (AMLA)

Dimensions and weight

22 DN09236379 Issue: 01 DRAFT
   

Nokia AirScale Radio Description AirScale RRH 4T4R B66 160W (FRIJ)

Table 16 FRIJ dimensions and weight
Property Value Dimensions orientation
Height With cover: 600 mm (23.6 in.) Dimensions orientation in
vertical mount with cover
With cover and fan: 630.2 mm
(24.8 in.)

Depth With cover and handle: 409.5:
mm (16.1 in.)
With cover, fan and handle:
409.5 mm (16.1 in.)
width
DRAFT VERSION

Width With cover: 126 mm (5.0 in.)
height
With cover and fan: 126 mm depth
(5.0 in.)
Dimensions orientation in
horizontal mount with cover
Weight 21 kg (46.3 lbs) and fan

width
Volume With cover: 28 l
Without cover: 20.4 l height
depth

Environmental specifications

Table 17 FRIJ environmental specifications
Property Value
Maximum operational outdoor temperature in +55°C (131°F)
the shade, assuming wind speed is 3 m/s (at
constant high ambient temperature, maximum
output power might be limited)
Maximum operational outdoor temperature in +50°C (122°F)
the sun, assuming wind speed is 3 m/s (at
constant high ambient temperature, maximum
output power might be limited)
Maximum indoor temperature, assuming wind +40°C (104°F)
speed is 0 m/s, valid for fanless products (at
constant high ambient temperature, maximum
output power might be limited)
Minimum operational temperature (including -40°C (-40°F)
cold start)

LEDs

Issue: 01 DRAFT DN09236379 23
   

AirScale RRH 4T4R B66 160W (FRIJ) Nokia AirScale Radio Description

Table 18 FRIJ LEDs
LED color Description Alarm
Red, stable Critical alarm affecting the Fault
whole RF module or all
antenna carriers
Red, blinking Operation degraded Major/critical alarm
• Major alarm affecting the
whole RF Module
• Critical alarm affecting
fans
• Major/Critical alarm
DRAFT VERSION

affecting a module
subcomponent or antenna
carrier

Yellow, stable • Until software download No alarm


begins
• The carriers are blocked
from BTS
• There is no connection to
any System Module

Yellow, blinking • Software download in No alarm


progress
• Configuration in progress:
RF resources are being
setup, but not yet activated

Green, stable • Software configuration is No alarm


complete or supervisory:
RF resources activated
and transmission is
possible
• Working normally, no
alarm on the RF Module

Green, blinking Software downloading and No alarm


updating
Stable Red for less than 5 Switched ON, but the next No alarm
seconds and changes to conditions are not reached yet
Stable Yellow
Stable Red for less than 5 The module is in the process No alarm
seconds of resetting
Periodic Red and Green Antenna line device No alarm
faulty/degraded
Blinking Colors (Red, Yellow, Module highlighting (Flexi BTS No alarm
and Green), each color stable SM functionality that can help
for 0.5 second identifying faulty module)

Warnings, cautions or notes related to the product

f WARNING! The module is heavy. Risk of personal injury!


Do not remove or relocate factory installed stopping screws from mounting brackets or
AMPA.

24 DN09236379 Issue: 01 DRAFT
   

Nokia AirScale Radio Description AirScale RRH 4T4R B66 160W (FRIJ)

f WARNING! Lift only one module at a time!


Use the designated lifting point only. Do not pre-assemble and lift multiple units on
AMPA.

f WARNING! Install only three modules per side in vertical book mount!
Mount the secondary center module bracket to the pole bracket with four M8 screws.
Only one module is allowed on each side of the center bracket.

f WARNING! Do not connect secondary brackets in wall installation!


Mount each module to its own secondary bracket and install each secondary bracket to
the wall individually.

w NOTICE: To ensure proper cooling for an RRH mounted in the vertical position, it
DRAFT VERSION

should always be mounted with the connectors on the bottom side. For horizontal
mounting, fans are required.

g Note: The minimum startup voltage is 40.5 V DC. If the input voltage is below/beyond
extended limits, the unit might shut down.

Issue: 01 DRAFT DN09236379 25

You might also like