Invicta 3 Distribution Board User Instructions: RCCB Blank Rcbo (2 Module) Rcbo (1 Mod) MCB Switch

You might also like

Download as pdf or txt
Download as pdf or txt
You are on page 1of 1

Invicta 3 Distribution Board

User Instructions
Your property has been equipped with a hager Distribution Board. This unit RCCBs and RCBOs should be tested every 3 months. Press the TEST
and it’s associated hager protective devices will offer the highest level of or T button. The device should trip (go to the OFF position). If it trips,
protection for your premises. reset the device by pushing the toggle to the up (ON) position. If it does
not trip call a qualified electrician.
A range of possible protective devices may be installed in your consumer
INV USER

unit, including Miniature Circuit Breakers (MCBs), Residual Current Circuit ONLY QUALIFIED ELECTRICIANS SHOULD REMOVE THE FRONT
Breakers (RCCBs), or combined MCB/RCDs (RCBOs). COVER.

MCBs and fuses are safety devices designed to operate in the event that If any of the protective devices have tripped please follow the flow
a circuit or appliance demands too much current. diagram below.

RCCBs are also safety devices but are designed to protect against fault IF IN DOUBT ALWAYS CONSULT A QUALIFIED ELECTRICIAN.
currents flowing to earth, and these reduce the risk of fire and electric
shock. RCBOs combine the operation of both the MCB and RCCB. HAGER TECHNICAL SUPPORT HELPLINE: 01952 675689.
Access to the devices is by lifting the tinted door.

ON ON ON
ON

Blank RCCB RCBO MCB RCBO Switch


(2 Module) (1 Mod)

* Important note Fuse carriers must not be opened or closed with the main
switch in the ON position.
START

Use circuit as MCB/Fuse Use circuit as


normal tripped normal

YES
MCB
or
RCBO RCCB
YES Does device What device Does device
Try & reset device once Try & reset device once
stay ON? is it? stay ON?

NO Fuse NO

Turn OFF
Turn OFF all MCBs / fuse*
NO Does device Main switch devices
Call an
electrician supply socket
outlets

Call an Reset RCCB


Pull down fuse* carrier electrician
YES handle and replace
Turn ON
blown fuse with
Main switch
Unplug all equivalent type &
appliances from rating, close carrier
circuit and reset NO Does device
device / replace fuse* stay ON?

Unplug faulty YES


Plug in & switch on
NO YES appliances one at a time appliance until Turn ON MCBs / fuses*
Does device
repaired. Reset device. devices one at a time
stay ON? until device trips / blows,
Other appliances may
INV USER

identifying faulty appliance until RCCB trips again,


be used identifying faulty circuit

Hager Ltd. Hortonwood 50 Telford Shropshire TF1 7FT • Sales Hotline: 01952 675612 • Technical Helpline: 01952 675689 INV USER

You might also like