Professional Documents
Culture Documents
MBH542 Owner's Manual
MBH542 Owner's Manual
1
Blue Indicator not light.
A. Before first time use, recharge the unit approximately 4 hours until the unit is fully charged.
TROUBLESHOOTING 1 x Owner’s Manual
B. Charge and store the unit within the temperature range of 5°C - 35°C (40°F - 95°F).
1 x USB Connection Cable (For Charging only)
C. Do not overcharge (longer than 24 hours). Excessive charging or running the unit until Check the following before requesting service:
1 x Audio Connection Cable with 3.5 mm plugs
battery fully drains will damage battery. Battery life will be extended if you keep the battery SYMPTOM POSSIBLE CAUSE POSSIBLE SOLUTION
fully charged. Can't power on Built-in battery drained Recharge the battery as page 3
Notes:
D. Battery life naturally shortens slowly over time.
No sound or Volume of the unit was set to minimum Increase the volume by press and
When the external BT Device searched the unit, our model number “MBH542” will
E. The rechargeable battery incorporated in this product is not user replaceable. SPECIFICATIONS AND ACCESSORIES ARE SUBJECT TO CHANGE WITHOUT
sound weak position holding the Button on the unit
appear on the display of external BT Device.
Volume level of paired/connected device is Rise the volume level of the
NOTICE
If while pairing you are asked for a code please try "0000" or "1234".
in low level paired/connected device
Normal operation after paired: Sound Volume level too high Reduce the volume level by press
and holding the Button on the
1. Power on the external BT Device and enter to BT mode. distortion unit
For first time use or re-pairing the unit to a new BT Device, pairing it as
2. Press and holding the Button approximately 3 seconds to power on the unit. The Volume level of the Reduce the volume level of the
below:
1. Button Blue & Red Indicators will illuminate & blink. paired/connecteddevice too high paired/connected device
1. Press and holding the Button approximately 3 seconds to power on the unit. The
2. Micro USB Port (For Charging Only) 3. Wait a few seconds until the unit automatically pair to the BT Device. When paired, the BT not The external BT device had NOT paired to Pair the external BT device to the
Blue & Red Indicators will illuminate & blink.
3. LED Indicators Blue LED Indicator will stop blinking and Red LED Indicator will turn off. functioning
2. Power on the external BT Device and enter to BT searching mode. Start pairing following the unit unit as page 3-4
4. AUX (In) Jack 4. If pairing is complete you may now play music and answer the phone with your external
the on screen instructions from the external BT Device. When paired, the Blue LED The external BT device too far from the Place the external BT device close
5. Microphone BT Device.
Indicator will stop blinking and Red LED Indicator will turn off. unit to the unit
6. Button 3. If pairing is complete you may now play music and answer the phone with your external Audio Connection Cable was inserted into Unplug the Audio Connection Cable
7. Button BT Device. the AUX (In) Jack from the AUX (In) Jack before use
BT
1 2 3 4 5 6