Professional Documents
Culture Documents
Art Combitrim PDF
Art Combitrim PDF
Art Combitrim PDF
Originalbetriebsanleitung
Original instructions
Notice originale
Manual original
Manual original
Istruzioni originali
Oorspronkelijke
gebruiksaanwijzing
Original brugsanvisning
Bruksanvisning i original
Original driftsinstruks ART COMBITRIM
Alkuperäiset ohjeet
Πρωττυπο οδηγιών
χρήσης
Orijinal iµletme talimat∂
Instrukcja oryginalna
PÛvodní návod k pouÏívání
Pôvodn˘ návod na pouÏitie
Eredeti használati utasítás
Оригинальное руководст-
во по эксплуатации
Оригінальна інструкція з
експлуатації
Instrucøiuni originale
Оригинална инструкция
Originalno uputstvo za rad
Izvirna navodila
Originalne upute za rad
Algupärane kasutusjuhend
Instrukcijas oriinālvalodā
Originali instrukcija
Deutsch Polski
English âesky
Français Slovensky
Español Magyar
Português Русский
Italiano Українська
Nederlands Românå
Dansk Български
Svenska Srpski
Norsk Slovensko
Suomi Hrvatski
Eλληνικά Eesti
Türkçe Latviešu
Lietuviškai
360°
16
13
15
14
3 17
13
5
7
12
11
9 10
A B1
10
➋ 6
➊
➊
!
CK
CLI
11
7
➋
B2 B3
18
19
18
11
C D
90°
➋
➊ ➊
6
➋
3 4
E F
6
➊ ➌
18
➋
11
6
90¡
12
G H
6 ➊
12 ➋ 5
90°
I J
9
K L
20
M N
26
27
25
21
22
25
23
O
10 24
13
14 CLICK!
Safety Notes
Warning! Read these instructions carefully, be ■ This appliance is not intended for used by per-
familiar with the controls and the proper use of sons (including children) with reduced physical,
the line trimmer. Please keep the instructions sensory or mental capabilities, or lack of experi-
safe for later use. ence and knowledge, unless they have been
Explanation of symbols on the line trimmer given supervision or instruction concerning use of
the appliance by a person responsible for their
General hazard safety alert. safety.
Children should be supervised to ensure that they
do not play with the appliance.
Read instruction manual.
■ Never work with this trimmer while people, espe-
cially children or pets are nearby.
Wear eye protection. ■ The operator or user is responsible for accidents
or hazards occurring to other people or their prop-
erty.
■ Wait until the rotating line has completely stopped
before touching it. The line continues to rotate af-
ter the trimmer is switched off, a rotating line can
360°
cause injury.
■ Work only in daylight or in good artificial light.
■ Avoid operating the trimmer in wet grass, where
feasible.
Beware of thrown or flying objects to bystanders.
■ Switch off when transporting the trimmer to and
Keep bystanders a safe distance away from the ma- from the area to be worked on.
chine.
■ Switch on the trimmer with hands and feet well
Switch off and remove plug from mains be- away from the rotating line.
fore adjusting, cleaning or if the cable is en-
tangled and before leaving the trimmer unat- ■ Do not put hands or feet near the rotating line.
tended for any period. Keep the supply flex- ■ Never fit metal cutting elements to this trimmer.
ible cord away from the cutting line. ■ Inspect and maintain the trimmer regularly.
Do not work in the rain or leave the trimmer ■ Have the trimmer repaired only by an authorized
outdoors whilst it is raining. customer service agent.
■ Always ensure that the ventilation slots are kept
■ Never operate the trimmer with damaged guards clear of debris.
or shields or without guards or shields in position.
■ Take care against injury from the blade fitted for
■ Before use check the supply and extension cord cutting the nylon line length. After feeding line al-
for signs of damage or ageing. If the cord be- ways return the trimmer to its horizontal operating
comes damaged during use, disconnect the cord position before switching on.
from the supply immediately. DO NOT TOUCH
THE CORD BEFORE DISCONNECTING THE ■ Do not feed and cut off excess line in edging po-
SUPPLY. Do not use the trimmer if the cord is sition.
damaged or worn. ■ Switch off and remove the plug from the
■ Before using the machine and after impact, check socket:
for signs of wear or damage and repair if neces- – whenever you leave the machine unattended for
sary. any period
■ Do not operate the trimmer when barefoot or – before replacing the spool
wearing open sandals, always wear substantial – if the cable is entangled
footwear and long trousers.
– before cleaning or working on the line trimmer.
■ Keep extension cords away from cutting ele-
ments. ■ Store the machine in a secure dry place out of
reach of children. Do not place other objects on
■ Never allow children or people unfamiliar with
top of the machine.
these instructions to use the trimmer. Local regu-
lations may restrict the age of the operator. When ■ Replace worn or damaged parts for safety.
not in use store the trimmer out of reach of chil- ■ Ensure replacement parts fitted are Bosch ap-
dren. proved.
Technical data
Do not feed and cut off excess line in edg- Fitting Extra Strong Line Spool
ing position (see figure J). Feed button 20 Hold the spool plate 23 in position.
may become hot. Turn the spool cover 21 counter-clockwise and re-
The rotating line can wear or break. You will notice move.
when the motor runs without load and no grass is
cut.
Place the Extra Strong Line spool 14 on the spool Build in the spool as described above.
plate in the correct position (bayonet fastening), Note: Only use Bosch replacement line. It has been
press down and turn fully clockwise (click). developed specially for improved cutting and feed-
O When the Extra Strong Line breaks, us the ing performance. The use of other line will lead to a
above procedure to remove the spool and fit the Ex- deterioration in performance.
tra Strong replacement Line 13 as shown to the
spool.
Replacement Extra Strong Line can be stored on the After Trimming/Storage
product as shown in main figure.
Stop and remove plug from the power sup-
N Refilling Line ply.
Take out the spool 25 as described above. Clean the exterior of the machine thoroughly using a
Press the cover ring 27 together, push it forward and soft brush and cloth. Do not use water, solvents or
detach over the smaller diameter of the spool. polishes. Remove all grass and debris, especially
from the ventilation slots 8.
Cut off approx. 8 m line from the refill roll. Press one
end into the notch of the spool so that it stands out Turn the machine on its side and clean the cutting
approx. 4 mm. guard 10 inside. If grass cuttings are compacted, re-
move with a wooden or plastic implement.
Wind on the line tightly and in orderly layers in arrow
direction. Hang the cable on the hook provided. DO NOT
wrap/loop the supply/extension cable around the
Thread the line’s end through the slot 26 in the cover
hook and the guard together – this will cause the ca-
ring 27 from the inside.
ble to be in contact with the guard blade which can
Keep the line tight and slide the cover ring 27 over damage the cable. ONLY hang the cable on the
the smaller diameter of the spool. hook provided.
Fault Finding
The following table gives checks and actions that you can perform if your machine does not operate correctly.
If these do not identify/remedy the problem, contact your service agent.
Warning: Switch off and remove plug from mains before investigating fault.
Inside Australia:
Disposal
Phone: +61 (01300) 307 044
Power tools, accessories and packaging should be Fax: + 61 (01300) 307 045
sorted for environmental-friendly recycling. Inside New Zealand:
Only for EC countries: Phone: +64 (0800) 543 353
Do not dispose of power tools into Fax: +64 (0800) 428 570
household waste!
According to the European Directive Outside AU and NZ:
2002/96/EC on waste electrical and Phone: +61 (03) 9541 5555
electronic equipment and its incorpo- www.bosch.com.au
ration into national law, products that
are no longer suitable for use must be separately
collected and sent for recovery in an environmen- Declaration of Conformity
tally-friendly manner.
Measured sound values determined according to
2000/14/EC (1.60 m height, 1 m distance away).
After-Sales Service and
Typically the A-weighted noise levels of the product
Customer Assistance are: sound pressure level 85 dB(A); sound power
level 95 dB(A). Uncertainty K=1 dB.
Our after-sales service responds to your questions Wear hearing protection!
concerning maintenance and repair of your product
as well as spare parts. Exploded views and informa- Vibration total values (triax vector sum) determined
tion on spare parts can also be found under: according to EN 60335:
www.bosch-pt.com Vibration emission value ah =3.5 m/s2, Uncertainty
Our customer consultants answer your questions K=2 m/s2.
concerning best buy, application and adjustment of We declare under our sole responsibility that the
products and accessories. product described under „Technical data“ is in con-
formity with the following standards or standardiza-
Great Britain tion documents: EN 60335 according to the provi-
Robert Bosch Ltd. (B.S.C.) sions of the directives 2004/108/EC, 98/37/EC (until
P.O. Box 98 28 Dec 2009), 2006/42/EC (from 29 Dec 2009),
Broadwater Park 2000/14/EC.
North Orbital Road 2000/14/EC: Guaranteed sound power level
Denham 96 dB(A).
Uxbridge Conformity assessment procedure according to An-
UB 9 5HJ nex VI.
Tel. Service: +44 (0844) 736 0109 Equipment category: 33
Fax: +44 (0844) 736 0146 Notified body: SRL, Sudbury, England, Nr. 1088
E-Mail: SPT-Technical.de@de.bosch.com Technical file at: Bosch Lawn and Garden Ltd., PT-
LG/EAE, Stowmarket, Suffolk IP14 1EY, England
Ireland Leinfelden, 21.10.2009
Origo Ltd. Dr. Egbert Schneider Dr. Eckerhard Strötgen
Unit 23 Magna Drive Senior Vice President Head of Product
Magna Business Park Engineering Certification
City West
Dublin 24
Tel. Service: +353 (01) 4 66 67 00
Robert Bosch GmbH, Power Tools Division
Fax: +353 (01) 4 66 68 88
Australia, New Zealand and Pacific Islands Subject to change without notice
Robert Bosch Australia Pty.Ltd.
Power Tools
Locked Bag 66
Clayton South VIC 3169
Customer Contact Center