Professional Documents
Culture Documents
Ma en-GB
Ma en-GB
C30 2007, C30 2008, C70 (06-) 2007, C70 (06-) 2008, S40 (04-) 2007, S40 (04-) 2008, V50 2007, V50 2008 Replaces issue: 2006 12
IMG-263503
Page 1 of 20
Installation instructions, accessories - USB/iPod Music interface
Volvo Car Corporation Göteborg, Sweden
Required tools
A0000162 IMG-264163
IMG-263504
IMG-213320
Page 2 of 20
Installation instructions, accessories - USB/iPod Music interface
Volvo Car Corporation Göteborg, Sweden
Page 3 of 20
Installation instructions, accessories - USB/iPod Music interface
Volvo Car Corporation Göteborg, Sweden
● The second page shows the tools needed for the installation and
The cable between adapter and music player can be ordered for USB,
the contents of the installation kit
iPod, or both.
● Cut out the text page in order to follow the illustrations and text at
the same time.
Page 4 of 20
Installation instructions, accessories - USB/iPod Music interface
Volvo Car Corporation Göteborg, Sweden
1 Preparations
Applies to all models
Note!
Wait at least five minutes before disconnecting the connectors or removing other
electrical equipment.
A8800136
2 Preparations
Carefully bend loose the back of the centre console with a plastic weatherstrip
tool. It is secured by a lock catch on each long side.
J8504532
3 Preparations
Use a small screwdriver and press in the catches at one of the surround's upper
corners. Carefully prize the surround away on one side using a plastic
weatherstrip tool.
● Repeat the procedure for the other side and then fold the surround backwards
into the vehicle. Pull the surround up until it detaches.
J8504893 If there is difficulty removing the surround, press the panel back into place on both sides
and start the removal procedure again. Start from the opposite side to before.
4 Preparations
● Press out the display module from the back of the centre console's panel. Press
straight backwards, use both hands.
J8504534
Page 5 of 20
Installation instructions, accessories - USB/iPod Music interface
Volvo Car Corporation Göteborg, Sweden
5 Preparations
IMG-263505
6 Preparations
IMG-270743
7 Preparations
IMG-263584
8 Preparations
● Carefully bend loose and remove the hand brake lever's panel.
IMG-263585
Page 6 of 20
Installation instructions, accessories - USB/iPod Music interface
Volvo Car Corporation Göteborg, Sweden
9 Preparations
Steps 9—14 apply to the C70
● Remove the rear seat cushion by first pressing the outer edges of the cushion
backwards and then by pulling them upwards so that the outer hooks release.
IMG-263944
10 Preparations
● Lift the cushion straight up in the middle so that the inner hooks release.
IMG-263945
11 Preparations
● Remove the rear cup holder from the rear tunnel compartment by prizing the front
edge and pressing in the two catches.
IMG-263946
12 Preparations
IMG-235031
Page 7 of 20
Installation instructions, accessories - USB/iPod Music interface
Volvo Car Corporation Göteborg, Sweden
13 Preparations
IMG-235032
14 Preparations
IMG-268146
15 Preparations
Applies to all models
● Remove the two screws along the front edge of the tunnel console.
IMG-270744
16A Preparations
Illustration A
Illustration B
● Carefully pull up the lock catch with special tool no. 9995919. At the same time,
slide the whole tunnel console backwards so that the two rear screws in the
centre console's panel can be accessed.
IMG-263586
Page 8 of 20
Installation instructions, accessories - USB/iPod Music interface
Volvo Car Corporation Göteborg, Sweden
16B
IMG-263587
17 Preparations
IMG-263588
18 Preparations
IMG-263589
19 Preparations
● Remove the two screws holding the centre console's panel to the dashboard.
J8504535
Page 9 of 20
Installation instructions, accessories - USB/iPod Music interface
Volvo Car Corporation Göteborg, Sweden
20 Preparations
● Remove the two clips securing the cables to the media player by first pressing
them to the sides and then pulling them away downwards.
Note!
Make sure that the optic cables are not bent or stretched. They may not be bent with a
radius less than 25 mm (1").
J3905272
21 Preparations
● Remove the two screws from the bottom of the media player.
● Pull out the media player and detach the connectors on the rear side.
J3904501
22A Preparations
Illustration A
Illustration B
● Unplug the big grey connectors at the leading edge from each other.
IMG-263590
22B
IMG-263591
Page 10 of 20
Installation instructions, accessories - USB/iPod Music interface
Volvo Car Corporation Göteborg, Sweden
23 Preparations
Steps 23-24 apply to both the C30, S40 and V50
IMG-263592
24 Preparations
● Carefully bend loose the tunnel console's rear panel using a weatherstrip tool.
IMG-263593
25 Installation
Applies to all models
● Get the USB/iPod cable from the kit, insert the straight contact in the trailing edge
of the tunnel console and into the storage compartment.
IMG-263595
26 Installation
● Measure the length of the cable that is to be protrude from the bottom of the
storage compartment.
IMG-263597
Page 11 of 20
Installation instructions, accessories - USB/iPod Music interface
Volvo Car Corporation Göteborg, Sweden
27 Installation
● Clamp in the cable harness to the existing cable harness using cable ties.
IMG-263598
IMG-263600
29
● Connect the connector to the 12V socket.
IMG-263601
● Reinstall the tunnel console, but do not slide it forward so that it covers the rear
screw holes for the centre console's panel.
Illustration B
IMG-263602
Page 12 of 20
Installation instructions, accessories - USB/iPod Music interface
Volvo Car Corporation Göteborg, Sweden
30B
IMG-263603
31
● Fold the carpet to the right of the center console.
IMG-263604
32
● Get the adapter cable and insert the fibre cable with black connector on the right
side in the centre console to the spot where the USB/iPod cable was routed.
Note!
Fibre optic cables may not be bent with a radius less than 25 mm (1").
Make sure that the cables are routed so that there is no risk of chafing.
IMG-263605
33
● Take the adapter from the kit and bend the mounting in at each end.
IMG-262106
Page 13 of 20
Installation instructions, accessories - USB/iPod Music interface
Volvo Car Corporation Göteborg, Sweden
34
● Get the pieces of foam tape and remove the protective tape.
IMG-262107
35A
Illustration A
Illustration B
IMG-262108
35B
IMG-262109
36
● Connect the USB/iPod connector and the fibre optic cable's connector to the
adapter.
● Clamp the USB/iPod cable at the eyelet on the adapter using a tie-strap.
IMG-263611
Page 14 of 20
Installation instructions, accessories - USB/iPod Music interface
Volvo Car Corporation Göteborg, Sweden
37
● Place the adapter high up on the cowl panel and against the right-hand side of
the centre console.
Note!
IMG-263613
38
● Plug in the big male connector (1) on the adapter cable to the media player.
● Plug in the grey female connector (2) on the adapter cable to the corresponding
connector (3) that was disconnected from the media player.
● Plug in the connector (4) on the adapter cable's fibre cable to the media player.
● Plug in the remaining connectors (5) on the fibre cables to each other.
● Plug in the remaining connectors that were disconnected from media player.
IMG-263614
39
IMG-263624
40
IMG-263625
Page 15 of 20
Installation instructions, accessories - USB/iPod Music interface
Volvo Car Corporation Göteborg, Sweden
41
● Reinstall the centre console's panel. Plug in the connector for the climate panel.
IMG-263626
42
IMG-263627
43
IMG-263628
44A
IMG-263629
Page 16 of 20
Installation instructions, accessories - USB/iPod Music interface
Volvo Car Corporation Göteborg, Sweden
44B
IMG-263630
45
IMG-272584
46
IMG-263631
47
IMG-263632
Page 17 of 20
Installation instructions, accessories - USB/iPod Music interface
Volvo Car Corporation Göteborg, Sweden
48
IMG-263634
49
● File a slot in the storage compartment's bottom cover for the USB/iPod cable in
the position as shown.
IMG-263635
50
● Place the USB/iPod cable in the bottom cover's slot and pres it into place.
IMG-263637
51
IMG-263636
Page 18 of 20
Installation instructions, accessories - USB/iPod Music interface
Volvo Car Corporation Göteborg, Sweden
52
IMG-263638
53
IMG-263703
IMG-272585
55
IMG-272586
Page 19 of 20
Installation instructions, accessories - USB/iPod Music interface
Volvo Car Corporation Göteborg, Sweden
56
IMG-263947
57
IMG-272587
58
IMG-272588
59
IMG-242267
Page 20 of 20