Professional Documents
Culture Documents
How To Change Your Siemens SL56 OEM Housing
How To Change Your Siemens SL56 OEM Housing
11) After removing the main 12) Slide open the phone all
board, we are ready to the way to its top.
remove the slider.
Powered by Denkigroove
13) Using a flat tip (I used a 14) This is the trickiest part
screwdriver) push down on of the phone since you will
the 4 bays to unlock the need to simultaneously
slide. push both sides down to
loosen it.
21) Now remains the 22) Now that you have all
earphone casing. With a flat your display and earphone
tip, carefully lift the casing electronics transferred to
and remove it. Now you are your new housing, you are
ready to transfer all the ready for your next
electronics over to your new modification.
housing.
25) You can now place the 26) Optional: you can
white layer over the new tighten your slider by
keypad. Notice that there it CAREFULLY lifting the two
mounts perfectly on the metal tabs. Don’t
casing! overextend it or it will break!
27) Now you are ready to 28) Now you can connect
place the 2nd piece back the ribbon to the main
onto the slide. Remember board.
to loop the ribbon through
first.
Powered by Denkigroove
29) The ribbon should 30) Now you can insert the
simply snap on. main board, bottom end
first, back on.
31) The board is a perfect 32) Now you can place your
fit. rear top plate back on as
well.
Powered by Denkigroove
33) Now you are ready to 34) Place battery back on.
place your screws back on.