ROI NO. saesentennssr total Pages 04
D-180260
B. Tech. EXAMINATION, 2018
Semester V (CBS)
GEOTECHNICAL ENGINEER
CE-503
www.zoomy.in
Maximum Marks : 60
ING-II
Time : 3 Hours
The candidates shall limit their answers precisely within
the answer-book (40 pages) issued to them and no
supplementary/continuation sheet will be issued.
Note : Attempt any Five questions. Assume any missing
data suitably.
1, 45 Describe with neat sketch percussion drilling
for advancing boreholes into sub-soil. What are
its merits and demerits ? 5
toy Sketch a thin wall sampler explaining its parts.
Lok 4
- What are various types of samples that could
* be recored from subsurface ? ‘ 3
". Qos) W-D-180260
: PTO.2, How do you decide depth and lateral extent of
exploration ? Give guidelines for various Civi
. Engineering structures. 2
3. fay
4. (a)
»)
5. (ey
illustrate Coulomb Wedge Theory for active
earth pressure and passive earth pressure of dry
cohesionless soil with the help of neat labelled
sketch a retaining wall showing various forces
acting on it. Also plot force polygon in each
case. 8
‘What are tension cracks ? Upto what height,
the cohesive soil having undrained cohesion of
1.1 m2, will stand vertically without any lateral
support. The bulk unit weight of soil is
1.8 vm}, 4
Draw Mohr circles for Rankine's active and
passive states of plastic equilibrium showing
direction of failure planes. 5
What is earth pressure at rest ? Derive an
equation for determining the magnitude of earth
Pressure at rest condition. 7
How would you predict the type of shear failure
Occurring in various types of soils? ~ 4
W-D-180260 z(bY What are the modifications recommended in
the design parameters by [S Code to take into
account the effect of local shear failure ?. 4
AY Explain Meyerhof's concept of useful width for
the design of footings with eccentric loads. 4
6. (a) How would you interpet the net loading intensity
for a given permissible settlement in case of
sands from the results of plate load test? 4
(b) A footing, 2m square, rests on NC clay with its
base at a depth of 1.5 m from the ground
surface. The clay layer is 3.5m thick and is
underlain by a firm sand layer. The clay has the
following properties :
Liquid limit (w,) = 30%, natural water content
(w,) = 40%, specific gravity of solids (G) =
2.70, undrained cohesion (c,) = 0.5 kg/cm?.
Determine net safe bearing capacity of the
footing. Compute the settlement that would
result if this load intensity were allowed to act
on the footing. Natural water table is quite close
to the ground surface. 8
(2-05/18) W-D-180260 3 7 P.T.O.7. (a) Avhat are the situations that could lead to the
development of negative skin friction in a pile
foundation ? . : 5
Oy verermine ultimate load capacity of a square
pile group consisting of 9 piles, 10 m long, 30
cm diameter, 90 cm c/c spacing installed in a
clayey soil having ‘unconfined compressive
strength (UCS) = 1.5 kg/cm? and adhesion factor
(a) = 0.8. / 7
8. (a) What is the meaning of the following terms :
‘Uniform settlement, Differential settlement,
Angular distortion and Tilt ? 4
(b) What are under-reamed piles. Under what
circumstances are they recommended. Give
various steps for construction of under-reamed
piles. 8
W-D-180260 900