Professional Documents
Culture Documents
For The Detection of LP Gas: Applications: Features
For The Detection of LP Gas: Applications: Features
The figure below represents typical sensitivity characteristics, all data having been gathered at standard test conditions (see
reverse side of this sheet). The Y-axis is indicated as sensor resistance ratio (Rs/Ro) which is defined as follows:
Rs = Sensor resistance in displayed gases at various concentrations
Ro = Sensor resistance in 1800ppm of iso-butane
Air Air
10 10 Ethanol
Rs/Ro Rs/Ro
Ethanol
1 Hydrogen 1 Hydrogen
Methane Methane
Iso-butane Iso-butane
Propane Propane
0.1 0.1
100 1000 10000 100000 100 1000 10000 100000
Gas concentration (ppm) Gas concentration (ppm)
IMPORTANT NOTE: OPERATING CONDITIONS IN WHICH FIGARO SENSORS ARE USED WILL VARY WITH EACH CUSTOMER’S SPECIFIC APPLICATIONS. FIGARO STRONGLY
RECOMMENDS CONSULTING OUR TECHNICAL STAFF BEFORE DEPLOYING FIGARO SENSORS IN YOUR APPLICATION AND, IN PARTICULAR, WHEN CUSTOMER’S TARGET
GASES ARE NOT LISTED HEREIN. FIGARO CANNOT ASSUME ANY RESPONSIBILITY FOR ANY USE OF ITS SENSORS IN A PRODUCT OR APPLICATION FOR WHICH SENSOR HAS
NOT BEEN SPECIFICALLY TESTED BY FIGARO.
Basic Measuring Circuit:
The sensor requires two voltage inputs: A common power supply circuit can
heater voltage (VH) and circuit voltage be used for both VC and VH to fulfill the
(VC). The heater voltage (VH) is applied sensor's electrical requirements. The
to the integrated heater in order to value of the load resistor (RL) should be
maintain the sensing element at a specific chosen to optimize the alarm threshold
temperature which is optimal for sensing. value, keeping power dissipation (PS)
Circuit voltage (VC) is applied to allow of the semiconductor below a limit of
measurement of voltage (VOUT) across 15mW. Power dissipation (PS) will be
a load resistor (RL) which is connected highest when the value of Rs is equal
in series with the sensor. to RL on exposure to gas.
iso-butane in air
Test gas conditions
at 20±2˚C, 65±5%RH 3.6±0.1 3.6±0.1
Standard test Vc = 5.0±0.01V DC Bottom view
Circuit conditions
conditions VH = 5.0±0.05V DC
4 1 4 1
Conditioning period 90˚ 3.6±0.1 90˚ 3.6±0.1
7 days 3 2 3 2
before test ø5.1 ø5.1
u/m:mm
Pin connection:
1: Heater
The value of power dissipation (PS) can Sensor resistance (Rs) is calculated with 2: Sensor electrode (-)
be calculated by utilizing the following a measured value of VOUT(VRL) by using 3: Sensor electrode (+)
formula: the following formula: 4: Heater
PS = (VC - VRL)2 RS = ( VC - 1) x RL
RS VRL FIGARO USA, INC.
121 S. Wilke Rd. Suite 300
For information on warranty, please refer to Standard Terms and Conditions of Sale of Arlington Heights, Illinois 60005
Figaro USA Inc. All sensor characteristics shown in this brochure represent typical Phone: (847)-832-1701
characteristics. Actual characteristics vary from sensor to sensor. The only characteristics Fax: (847)-832-1705
warranted are those in the Specification table above. email: figarousa@figarosensor.com
REV: 01/14