Professional Documents
Culture Documents
Computer Architectutre Manual 3 2019-Cpe-27 Muhammad Usama Saghar
Computer Architectutre Manual 3 2019-Cpe-27 Muhammad Usama Saghar
ENGINEERING
University College of Engineering &
Technology Bahauddin Zakariya
University, Multan.
Manual Details
Submission Details
Manual No 03
Manual Title
Start programs Run write cmd then depress Enter (↵) key.
All we need to do is type in the command and then depress Enter (↵) key.
These debug commands are the tools a programmer needs to enter, execute,
and debug programs. At the completion of the operation, results are displayed
on the screen and the DEBUG prompt (−) is redisplayed. The PC waits in this
state for a new entry.
b) Working on 64 bit operating system:
You have to install the DOSBox 0.7 program.
DOSBox is a program that emulates the functions of MS-DOS, including sound,
graphics, input, and networking.
Step 1:
Download the appropriate version of the program for your operating system,
then Install the emu 8086 setup on your computer.
Step 2:
Make a folder for you to use it when you need to run MS-DOS commands .Create your
folder on D:\ drive for example then name it 8086.
Step 3
This window will appear then click next
Step 4
In this window some of emu8086 information will present read out carefully and
then click next.
Step 5
Select the location where software will install. By default c drive is selected I will prefer
go with this default setting and click next
Step 6
Setup will create the program shortcut in the following start menu folder click next
Step 7
Click install to continue with the installation.
Step 8
Wait while setup install emu8086 on your computer
Step 9
Setup has finished installing emu8086 emulator on computer select launch the emulator
and then finish
This window appears and it show that you have successfully installed the software.