Professional Documents
Culture Documents
Ac 182
Ac 182
Control heaters
Control heaters protect the control cabinet components from condensation during standby and prevent corrosive
damage of electrical and mechanical components in high humidity environments.
A362-2 = A 120 V AC; A363-2 = 240 V AC
* Heater kits for the PCC 3100 can also be used with the Detector Control.
©2010 Cummins Power Generation Inc. All rights reserved. Cummins Power Generationand Cummins are registered trademarks of Cummins Inc.
“Our energy working for you.” is a trademark of Cummins Power Generation. Specifications are subject to change without notice.
AC-182a (4/10) Page 1 of 4
Image 1: 0300-4515-01/02
Image 2: 0333-0645-01/02
Image 3: 0333-0661-01/02
Material: Silicone rubber heater with 1/8” thick silicone sponge insulation on heater bottom
o o o
Thermostat: Temp setpoint – 65 F (18.3 C) 10 oF (5.6 C)
Certification
Warning: Back feed to a utility system can cause electrocution and/or property damage. Do not connect generator sets to any building
electrical system except through an approved device or after building main switch is open.
Warning: For professional use only. Must be installed by a qualified service technician. Improper installation presents hazards of electrical
shock and improper operation, resulting in severe personal injury and/or property damage.