Professional Documents
Culture Documents
HW 13
HW 13
9. From the collector characteristic curves and the dc load line in Figure 5– 35, determine the
following:
( a) Collector saturation current
( b) VCE at cutoff
( c) Q- point values of IB, IC, and VCE
Figure 5– 35
Figure 5– 36
12. The bias resistor R2 in Figure 5– 36 is replaced by a 15 kΩ potentiometer. What minimum
resistance setting causes saturation?
13. If the potentiometer described in Problem 12 is set at 2 kΩ, what are the values for IC and
VCE?
14. Determine all transistor terminal voltages with respect to ground in Figure 5– 37. Do not
assume a “stiff” voltage divider this time.
Figure 5– 37
16. ( a) Determine VB in Figure 5– 38. Do not assume a “stiff” voltage divider this time.
( b) How is VB affected if the transistor is replaced by one with a βDC = 50?
Figure 5– 38
17. Determine the following in Figure 5– 38. Do not assume a “stiff” voltage divider this time.
( a) Q- point values
( b) The minimum power rating of the transistor.
Based upon:
FLOYD, THOMAS L., ELECTRONIC DEVICES (CONVENTIONAL CURRENT VERSION), 9th Ed., © 2012. Reprinted by
permission of Pearson Education, Inc., Upper Saddle River, NJ.