BENCHMARK
GPmork™ DETAIL Xmork™ DETAIL
3.125 19808 ——e|
(PIN CONNECTION LENGTH)
0.125 See Note 2 1.625 Min.
See Note 2 —=| Pit Free Zone
See Note 5
1 \ See BENCHIARK PRWMARY WAKE-UP SHOULDER SECONDARY MAKE-UP. SHOULDER
\ (Seal) (PIN NOSE / MECHANICAL STOP)
a4 Kar
Bevel Dia. VW
3.219 ‘iit _ || 2.325 #008
Bevel Dia. “TT (PIN. NOSE DIAMETER)
NOTES: |
1. Lead tolerance: 4)
a, For 2 inches +0:006 inch ——
b. Recut threads if stretch exceeds 0.006 inch in 2 inches.
2. Either benchmark type is applicable but not both.
0. GPmark: 0.125 is new condition, shall be 0.188 max. ofter refacng ms Thread toper 0.750" per ft
b. Xmark: 0,063 is new condition. After refocing a visible step ‘35 Threads per inch
cn the benchmark shall remain on the primary shoulder. See Note 4
Rethreading is required if there is no visible benchmark.
3. At Outside Diameter less thon 3.281, Bevel Diameter is void Break Edge
and 1/32" x 45° becomes effective, 1/82" Nox. x 45° Ref.
4, Surface finish requirement only applies during refacing operation See Note 3
5. Area of the connection where pitting is not permitted in the thread roots.
==) SESEE : .
rae _|B5 Risse" [Grant Pridecoyitriies rv XIN26
5195, [a] ajals]= ‘wellbore REFERENCE S
5 ft elglslslala| i ROY erica INFORMATION ONLY
ala! (FSESEI |e
aS 51 Tae = 1h
owe eT Te imc 1E920 [Tw [hs