Professional Documents
Culture Documents
A002 - Project - SKMM3523 Component Design 20192020 Sem 1
A002 - Project - SKMM3523 Component Design 20192020 Sem 1
A drum mixing system (as indicated in Figure 1.1) needs to be designed to blend liquid resin
for plastic blending factory. The specifications are as shown in the diagram. You are required
to use V-Belt system and Gear System.
Basic Requirement:
i. Drum rotating at 30 rpm CW.
ii. Stirrer turning at 60 rpm CCW.
iii. Stirrer arm translating up and down at
30 mm per minute.
iv. Powered by Motor 600 rpm and 1/3 hp.
1/3
MINOR PROJECT 1
MAJOR PROJECT
i. Select the suitable motor from those that are available in the market
ii. Analyse all the shafts in the system.
iii. Analyse all the gears in the system.
iv. Select the suitable v-belt for the system.
v. Select the suitable bearings for the system.
vi. Put all answers in one table.
___________________________________________________________________________
REPORT GUIDELINES
The report must be submitted using the following guidelines
END
2/3