Professional Documents
Culture Documents
QSG HMI Current Version
QSG HMI Current Version
QSG HMI Current Version
g. Press OK. l. To change values, use or . To • HMI screens vary between models however; all feature
move between values, use or . ‘Main Menu: Network‘ with ‘DHCP Enabled or
b. Press . Disabled’.
Flashing m. Press OK.
• If you lose your way in the menu tree; press Esc
h. To change values, use or . To repeatedly to return to the top level menu and start again.
c. Press OK. move between values, use or .
• OK takes you into a submenu. Esc takes you out of a
n. Press Esc.
i. Press OK. submenu.
Flashing • Press OK (Confirm) applies changes.
d. To change values, use or . To move • To change values, use or . To move between values,
o. Press OK.
between values, use or . j. Press . use or .
p. Connect the network cable and ob-
e. Press OK. • If you do not find the HMI menu intuitive, go to the HMI
serve your IP address, e.g. below...
menu tree in the Operation and Firmware Manual on
k. Press OK. your USB pen drive.
f. Press .
ETL SYSTEMS LIMITED TELEPHONE FACSIMILE EMAIL Page 1
V3 E&OE
Coldwell Radio Station, Madley, Hereford, HR2 9NE, UK +44 1981 259020 +44 1981 259021 support@etlsystems.com
1 DHCP Enabled on Network c. Connect the unit to the network and 2 DHCP Not Enabled on Network
wait 20 seconds.
ETL units without HMI default to DHCP a. Connect your unit ethernet port to a PC.
enabled to allow a network to issue IP
settings. Use the ETL Discovery Tool to see
b. Click on the ‘Discover Devices’ button to
the IP address that has been issued...
refresh the list of connected ETL units.
d. Maximise the Discovery Tool
The Discovery Tool is saved on the USB pen
window and repeat Step 1b whilst
drive supplied with your unit and is also avail-
observing the window. A new IP address
able at:
will appear with (d) next to it. This is the
ftp:DiscoverTool:DiscoverTool@ftp.etlsystems.com
address of your unit.
Units without HMI use default IP settings b. Configure network settings that are in the d. The User Name is admin. The Password is Network Configuration screen:
when DHCP is not available. same subnet as the unit default on your PC. 1234.
IP Address 192.168.0.252
Subnet Mask 255.255.0.0
e. Select the Network Configuration tab to assign
Gateway 192.168.0.1
the static IP address your unit will use on your
network.