Professional Documents
Culture Documents
SDS CONPLAST SP439 India
SDS CONPLAST SP439 India
1.2. Relevant identified uses of the substance or mixture and uses advised against
Identified uses Superplasticizer for Cement & Concrete
Classification (67/548/EEC or -
1999/45/EC)
Inhalation Move affected person to fresh air at once. Get medical attention. Move affected person to
fresh air and keep warm and at rest in a position comfortable for breathing. When breathing is
difficult, properly trained personnel may assist affected person by administering oxygen.
1/7
Revision date: 24/03/2016 Revision: 4A
CONPLAST SP439
Ingestion Do not induce vomiting. Never give anything by mouth to an unconscious person. Do not
induce vomiting. Remove affected person from source of contamination. Give plenty of water
to drink. Get medical attention immediately. Promptly get affected person to drink large
volumes of water to dilute the swallowed chemical.
Skin contact Remove affected person from source of contamination. Remove contaminated clothing. Wash
skin thoroughly with soap and water. Get medical attention promptly if symptoms occur after
washing.
Eye contact Remove affected person from source of contamination. Remove any contact lenses and open
eyelids wide apart. Continue to rinse for at least 15 minutes and get medical attention.
4.2. Most important symptoms and effects, both acute and delayed
4.3. Indication of any immediate medical attention and special treatment needed
SECTION 5: Firefighting measures
2/7
Revision date: 24/03/2016 Revision: 4A
CONPLAST SP439
Long-term exposure limit (8-hour TWA): WEL 200 ppm(Sk) 266 mg/m3(Sk)
Short-term exposure limit (15-minute): WEL 250 ppm(Sk) 333 mg/m3(Sk)
WEL = Workplace Exposure Limit
Protective equipment
Eye/face protection The following protection should be worn: Chemical splash goggles.
Other skin and body Wear appropriate clothing to prevent any possibility of liquid contact and repeated or
protection prolonged vapour contact.
Hygiene measures Do not smoke in work area. Wash at the end of each work shift and before eating, smoking
and using the toilet. Promptly remove any clothing that becomes contaminated. Wash
promptly with soap and water if skin becomes contaminated. Use appropriate skin cream to
prevent drying of skin.
Respiratory protection No specific recommendations. Respiratory protection must be used if the airborne
contamination exceeds the recommended occupational exposure limit.
3/7
Revision date: 24/03/2016 Revision: 4A
CONPLAST SP439
Odour Odourless.
Melting point 0℃
Oxidising properties Does not meet the criteria for classification as oxidising.
10.1. Reactivity
Reactivity There are no known reactivity hazards associated with this product.
4/7
Revision date: 24/03/2016 Revision: 4A
CONPLAST SP439
Medical symptoms No specific symptoms noted, but this chemical may still have adverse health impact, either in
general or on certain individuals.
12.1. Toxicity
12.2. Persistence and degradability
Persistence and degradability The degradability of the product is not known. This product is not expected to be readily
biodegradable.
Disposal methods Dispose of waste to licensed waste disposal site in accordance with the requirements of the
local Waste Disposal Authority.
General The product is not covered by international regulations on the transport of dangerous goods
(IMDG, IATA, ADR/RID).
14.1. UN number
Not applicable.
5/7
Revision date: 24/03/2016 Revision: 4A
CONPLAST SP439
14.7. Transport in bulk according to Annex II of MARPOL and the IBC Code
Transport in bulk according to Not applicable.
Annex II of MARPOL 73/78
and the IBC Code
15.1. Safety, health and environmental regulations/legislation specific for the substance or mixture
National regulations The Chemicals (Hazard Information and Packaging for Supply) Regulations 2009 (SI 2009
No. 716).
EU legislation Regulation (EC) No 1272/2008 of the European Parliament and of the Council of 16
December 2008 on classification, labelling and packaging of substances and mixtures (as
amended).
General information The user must be instructed in the proper work procedure and be familiar with the contents of
these instructions.
Revision comments NOTE: Lines within the margin indicate significant changes from the previous revision.
Revision 4A
6/7
Revision date: 24/03/2016 Revision: 4A
CONPLAST SP439
The information on this data sheet represents our current data and is reliable provided that the product is used under the
prescribed conditions and in accordance with the application specified on the packaging and/or in the technical guidance
literature. Any other use of the product which involves using the product in combination with any other product or any other
process is the responsibility of the user.
7/7