Professional Documents
Culture Documents
MSDS - LHB Floral Aerosol Air Freshener
MSDS - LHB Floral Aerosol Air Freshener
MSDS - LHB Floral Aerosol Air Freshener
Section 3 Hazards Identification HANDLING: Keep out of reach of children. Keep away from heat, sparks, and open flame. Contents under
pressure. Do not puncture, incinerate, or expose to temperatures above 120°F. Heat from sunlight, radiators,
stoves, hot water, and other heat sources could cause container to burst. Do not take internally.
ROUTES OF EXPOSURE: Exposure may be by INHALATION and/or SKIN or EYE contact, depending on
STORAGE: CATEGORY – NFPA 30B Level 1 Aerosol
conditions of use. To minimize exposure, follow recommendations for proper use, ventilation, and personal
Do not store where temperatures may exceed 120°F (48.9°C).
protective equipment.
EFFECTS OF OVEREXPOSURE: Overexposure may result in light -headedness, staggering gait, giddiness, and
possible nausea. Intentional misuse by deliberately concentrating and inhaling the contents may be harmful or
fatal. May cause eye and skin irritation. Section 8 Exposure Controls/Personal Protection
SIGNS AND SYMPTOMS OF OVEREXPOSURE: Headache, dizziness, nausea, and loss of coordination are
indications of excessive exposure to vapors or spray mists. Redness and itching or burning sensation may ENGINEERING CONTROLS: Local Exhaust preferable. General exhaust acceptable if the exposure to materials
indicate eye or excessive skin exposure. in Section 2 is maintained below applicable exposure limits.
MEDICAL CONDITIONS AGRAVATED BY EXPOSURE: Pre-existing respiratory, skin, and eye disorders. RESPIRATORY PROTECTION: If personal exposure cannot be controlled to below applicable limits by
CANCER INFORMATION: For complete discussion of toxicology data refer to Section 11. ventilation, wear a properly fitted organic vapor/particulate respirator approved by NIOSH/MSHA for protection
against materials in Section 2.
GLOVES: None required for normal application or where a minimal skin contact is expected.
Section 4 First Aid Measures SKIN PROTECTION: Not normally necessary. Wash promptly when skin becomes contaminated.
EYES: None
OTHER PERSONAL PROTECTION DATA: Avoid contact with skin and eyes. Wash hands after using.
INHALATION : Not a hazard under normal use conditions. Rem ove from source of exposure.
SKIN CONTACT: Immediately flush skin with plenty of water while removing contaminated clothing and shoes.
Call a physician if irritation persists. Wash clothing and shoes before reuse.
EYE CONTACT: Immediately flush eyes with plenty of water for at least 15 minutes. Consult medical personnel
if irritation persists.
INGESTION: If swallowed, do not induce vomiting. Slowly dilute with 1 –2 glasses of water or milk and seek
medical attention. Never give anything by mouth to an unc onscious person.
DISPOSAL OF WASTE METHOD: Do not incinerate. Depressurize container. Dispose of in accordance with ADDITIONAL INFORMATION: This MSDS has been prepared in accordance with FED -STD 313D and meets
Federal, State, and Local regulations regarding pollution. the requirements of 29 CFR 1910.1200.
IMPORTANT NOTE: This information is furnished without warranty, expressed or implied, as to accuracy or
completeness. The information is obtained from various sources including the manufacturer and other third party
sources. The information may not be valid under all conditions nor if this material is used in combination with
other materials or any process. Final determination of suitability of any material is the sole responsibility of the
user.